Vehicle recall 10V252000 · June 10, 2010

2009 Volkswagen Routan

These vehicles may have been built with an improper routed wire harness that may have a condition where the lower sliding door hinge bracket can make contact and wear through the…

Summary

Volkswagen is recalling certain model year 2009 routan vehicles manufactured from June 2008 through July 2009. These vehicles may have been built with an improper routed wire harness that may have a condition where the lower sliding door hinge bracket can make contact and wear through the wire insulation. Contact with a 12V power feed circuit within the harness may cause a high resistive short circuit within the latch mechanism located inside of the sliding door.

Consequence

This could result in an overheated latch and a fire within the rear sliding door could occur.

Remedy

Volkswagen will inspect the sliding door wire track wire assembly and the sliding door power drive unit wire assembly for damage, repair/replace as necessary, tie strap the two harnesses together and route the harnesses under the sliding door weather strip. This service will be performed free of charge. The safety recall began on October 15, 2010. Owners may contact Volkswagen at 1-800-822-8987.

Notes

Volkswagen safety recall no. 97S8/T7.OWNERS may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to http://www.safercar.gov.