Equipment recall 98E035000 · October 19, 1998

Toyota Avalon, RAV4 and 1 more model

Equipment description: aftermarket theft deterrent systems used on 1998-1998 Toyota RAV4, avalon, and sienna model vehicles distributed by southeast Toyota distributors, Inc. In…

This is a recall of aftermarket equipment listed for the vehicles below. It applies only if the recalled part was installed on the vehicle.

Summary

Equipment description: aftermarket theft deterrent systems used on 1998-1998 Toyota RAV4, avalon, and sienna model vehicles distributed by southeast Toyota distributors, Inc. In the states of alabama, florida, georgia, north and south carolina. The alarm wiring harness plugs into the vehicle's ignition switch and the vehicle's ignition switch wiring harness plugs into the alarm harness to complete the circuit. A percentage of the female terminals used in the alarm connector were found to be defective, causing an "open circuit" condition when mated to the male ignition switch terminals.

Consequence

This condition can cause intermittent performance of the vehicle's electrical components such as the dash warning lights and/or HVAC fan speed controls. Also, the vehicle may not run smoothly and could stall.

Remedy

Dealers will inspect the date code label on the security system harness and any displaying the manufacturing/final date code will be replaced with newly produced harnesses. The date codes are: RAV4 - 6/24/98, 6/25/98, 6/26/98; sienna - 6/25/98, 6/26/98; and avalon - 6/30/98, 7/1/98, 8/31/98, 9/1/98, 9/2/98, and 9/3/98.

Notes

Owner notification is being handled by southeast Toyota distributors.owner notification began November 3, 1998. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact southeast Toyota distributor at 1-800-301-6859.ALSO contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).