Skip to content
AnyRecalls

2005 Bigdog Chopper recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

7 recalls found in NHTSA data as of September 22, 2026

For the 2005 Bigdog Chopper. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Bigdog been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Bigdog dealer can also check your VIN. Recall repairs are free.

2005 Bigdog Chopper recalls, newest first

December 18, 2007NHTSA 07V5800008,061 vehicles potentially affected

Structure › Body

Summary
On certain motorcycles, the rear fender strut attaching bolts can fail allowing the rear fender to detach from the motorcycle.
Consequence
This could occur without prior warning and could result in an injury or a crash.
Remedy
Dealers will remove existing strut bolts and replace with higher tensile strength attaching bolts and updated washers. Higher torque values will be observed when installing the replacement fasteners. The recall began on January 21, 2008. Owners may contact big dog at 316-267-9121.

This recall on nhtsa.gov

October 12, 2006NHTSA 06V3890002,494 vehicles potentially affected

Structure

Summary
On certain motorcycles, the long pivot bolt may bend or break during normal operation of the motorcycle.
Consequence
This could potentially cause the rear fender to abrade against the rear tire while the motorcycle is being driven. This condition could occur without any prior warning and could result in a crash.
Remedy
Dealers will replace the long pivot bolt and, if necessary, straighten the rear frame side panel. The short left side pivot bolt and pivot shaft may also be replaced free of charge. The recall began on November 1, 2006. Owners may contact big dog at 316-267-9121.

This recall on nhtsa.gov

August 11, 2006NHTSA 06V3050002,101 vehicles potentially affected

Electrical system

Summary
On certain motorcycles, the electronic harness control (ehc) module can fail resulting in a total shut down of the vehicle's electronic power.
Consequence
This condition could occur without any prior warning and could result in a crash.
Remedy
Dealers will replace the ehc modules free of charge. The recall began on September 19, 2006. Owners may contact big dog at 316-267-9121.

This recall on nhtsa.gov

August 9, 2006NHTSA 06V3010002,711 vehicles potentially affected

Electrical system › Ignition › Module

Summary
On certain motorcycles, the ignition modules are oriented within the battery tray in a way that makes the ignition module susceptible to vibration.
Consequence
This susceptibility to vibration may contribute to a stalling condition that could occur without any prior warning and result in a crash.
Remedy
Dealers will install a new ignition module mounting system free of charge. The recall began on August 25, 2006. Owners may contact big dog at 316-267-9121.

This recall on nhtsa.gov

January 25, 2006NHTSA 06V0190009,726 vehicles potentially affected

Structure › Motorcycle › Kickstand/center stand

Summary
On certain motorcycles, the kickstand spring may stretch and detach from the mounting bracket or the kickstand.
Consequence
This will allow the kickstand to deploy into the extended position and cause a crash.
Remedy
Dealers will install a new kickstand spring free of charge. The recall began on February 17, 2006. Owners may contact big dog at 316-267-9121.

This recall on nhtsa.gov

September 28, 2005NHTSA 05V4320003,294 vehicles potentially affected

Wheels › Lugs/nuts/bolts/studs

Summary
On certain motorcycles, the rear wheel hub bolts could loosen and back out allowing the hub and brake rotor to detach from the wheel with an associated loss of stopping power.
Consequence
This condition could occur without any prior warning and could result in a crash.
Remedy
Dealers will remove, clean and reattach the rear hub bolts free of charge. The recall began on October 14, 2005. Owners may contact big dog at 1-312-267-9121.

This recall on nhtsa.gov

April 14, 2005NHTSA 05V1490001,418 vehicles potentially affected

Power train

Summary
On certain motorcycles, the primary drive sprocket nut may back off the engine main shaft.
Consequence
This could cause the primary drive to lock up and cause a crash. This condition could occur without any prior warning.
Remedy
Dealers will inspect and replace the drive sprocket nut free of charge. The recall began on may 13, 2005. Owners may contact big dog at 316-267-9121.

This recall on nhtsa.gov

Owner complaints

Owners have filed 3 complaints about the 2005 Bigdog Chopper with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported
0
Fires reported
0
Injuries reported
0
Deaths reported
0

Most complained-about components

  1. Electrical system1
  2. Engine and engine cooling › Engine1
  3. Structure › Motorcycle › Kickstand/center stand1
  4. Vehicle speed control1
  5. Wheels1

Other Bigdog Chopper years

Other 2005 Bigdog models

Most recalled 2005 vehicles

  1. 2005 Honda Accord (24 recalls)
  2. 2005 Ford E-350 (16 recalls)
  3. 2005 IC CE (16 recalls)
  4. 2005 Thomas Built Buses SAF-T-Liner C2 (16 recalls)
  5. 2005 Honda Pilot (15 recalls)
All of 2005’s most recalled vehicles

Questions

Does the 2005 Bigdog Chopper have any recalls?
7 recalls found in NHTSA data as of September 22, 2026, covering: structure, electrical system, wheels, power train. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2005 Bigdog Chopper recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Bigdog dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2005 Bigdog Chopper?
3 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.