1985 Buick Regal recalls

Fuel system, gasoline

• Aftermarket equipment: applies only if this part was installed

Summary

Certain replacement fuel filters, fram brand name p/n G3727, with date codes X52911 through X60801 sequentially or X600141 and a mexico country or origin marking on the fuel filter housing manufactured from October 18, 2005, through March 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). The connector on the fuel filter was not manufactured to honeywell's specification. As a result, the o-ring may not seat correctly on the fuel line.

Consequence

This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur.

Remedy

Honeywell will notify owners and replace the fuel filters free of charge. The recall began on October 18, 2006. Owners may contact fram customer service at 1-800-890-2075 (option 1).

This recall on nhtsa.gov

Exterior lighting › Headlights › Switch

Summary

Under extended headlamp usage, circuitry in the headlamp switch panel might experience increased resistance and excessive heat buildup.

Consequence

Headlights would cycle on and off. Sudden loss ofheadlights under severe weather or nightimer driving conditions could resultin a vehicle crash.

Remedy

Replace headlight switch with modified switch.

This recall on nhtsa.gov

Structure

Summary

Small cracks may develop in the body pillar around the door striker bolt hole.

Consequence

Cracks would increase leading to difficulty in closingthe door and might allow door to come open during a crash, increasinglikelihood of injury to occupants.

Remedy

Install inner and outer reinforcement plate on both left and right body pillars.

This recall on nhtsa.gov

Vehicle speed control › Springs

Summary

The throttle return spring assembly may fail preventing the throttle from returning to the closed (idle) position when the accelerator pedal is released. Consequence of defect: engine speed may not decrease and loss of accelerator control could result in an accident without prior warning.

Remedy

Replace throttle return spring.

This recall on nhtsa.gov

Equipment › Other › Labels

Summary

The certification label located on the left front door did not include a required federal certification statement. Consequence of defect: vehicles do not comply with federal regulation 567.

Remedy

Labels containing correct information are being mailed and should be installed on the left front door.

This recall on nhtsa.gov

Structure › Body › Bumpers

Summary

The rear bumper may fracture during a rear end collision, puncture the fuel tank, and cause a fuel leak. Consequence of defect: a fuel leak creates the potential for a fire which could result in burn injuries to persons in or near the car.

Remedy

Replace the rear bumper brackets and the "l" shaped reinforcement with a "u" shaped full reinforcement.

This recall on nhtsa.gov

Visibility › Windshield

Summary

A loss of bonding adhesion between the paint and the windshield opening area could allow the windshield to separate during a 30 mile per hour frontal barrier test required by FMVSS 212, windshield retention. Consequence of defect: windshield separation during an accident could result in an unbelted occupant being ejected from the car and severly injured.

Remedy

Remove and reinstall windshield if a lack of paint bonding is evident.

This recall on nhtsa.gov

Seat belts › Front › Retractor

Summary

The vehicles were assembled with front seat belt retractors which may not perform adequately during a collision.

Remedy

The dealer will replace the left and right front seat belt retractors free of charge.

This recall on nhtsa.gov

Steering › Linkages › Tie rod assembly

Summary

The tie rods are part of the steering linkage and transmit turning movements to the wheels. The bolts that fasten the tie rods to their adjusters may not be tight enough. This could allow the tie rod to loosen and detach itself from the adjuster.

Remedy

The tie rod end bolts will be tightened without cost to the owner.

This recall on nhtsa.gov