2003 Cadillac Escalade recalls

Wheels › Hub

• Aftermarket equipment: applies only if this part was installed

Summary

Certain federal-mogul replacement wheel hub assemblies with the brand names: national, carquest p/nos. 515020, 515021, 515025, 515053, 515054, 515059, and 515060, shipped between January 23, 2006, and December 20, 2007, sold for light duty and medium duty trucks. The inboard retention nut used to maintain hub bearing assembly can loosen resulting in an ABS light indication, noise, and/or wheel separation.

Consequence

Wheel separation can result in a vehicle crash.

Remedy

Federal-mogul will notify customers and will replace the hub assembly free of charge. The recall began on February 7, 2008. Owners can contact federal-mogul toll-free at 877-489-6659.

This recall on nhtsa.gov

Fuel system, gasoline

• Aftermarket equipment: applies only if this part was installed

Summary

Certain replacement fuel filters, fram brand name p/n G3727, with date codes X52911 through X60801 sequentially or X600141 and a mexico country or origin marking on the fuel filter housing manufactured from October 18, 2005, through March 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). The connector on the fuel filter was not manufactured to honeywell's specification. As a result, the o-ring may not seat correctly on the fuel line.

Consequence

This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur.

Remedy

Honeywell will notify owners and replace the fuel filters free of charge. The recall began on October 18, 2006. Owners may contact fram customer service at 1-800-890-2075 (option 1).

This recall on nhtsa.gov

Seat belts › Rear/other

Summary

On certain crew cab pickup trucks and sport utility vehicles, the 2nd row center occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants, especially smaller occupants, seated in this position. Appropriate use of a child seat or booster seat, as recommended for small children, does improve the fit condition for this user group. In addition to instructions on proper infant and young child restraint (with child seats or boosters), special verbiage for restraining older child is included in the owner's manual. Also, the suggested seat belt fit/routing for adults, irrespective of seating position, is described in the owner's manual text.

Consequence

A lap portion of the seat belt routing that is not low and snug on the hips can allow the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.

Remedy

Dealers will cut open the guide loop, remove a portion of the loop, and then the remaining two sides should be folded over and secured with a retainer free of charge. The recall began on July 21, 2005. Owners may contact Cadillac at 1-866-982-2339, Chevrolet at 1-800-630-2438, GMC at 1-866-996-9463, or hummer at 1-800-732-5493.

This recall on nhtsa.gov

Service brakes, hydraulic

Summary

Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? Some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore.

Consequence

Consequently, the valve o-ring seal may fracture. Steering efforts may be slightly increased while braking or parking. Under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture.

Remedy

Dealers are to replace the hydro-boost relief valve. The recall began on June 18, 2004. Owners should contact Cadillac at 1-866-982-2339; Chevrolet at 1-800-630-2438; GMC at 1-866-996-9463; or hummer at 1-866-486-6376.

This recall on nhtsa.gov

Structure › Body › Door › Hinge and attachments

Summary

Certain sport utility vehicles fail to comply with requirements of federal motor vehicle safety standard no. 214, "side impact protection." these vehicles are built with four welds on the rear door upper hinge. On some of these vehicles, one or two of the welds may not be to specification.

Consequence

As a result, the door strength may be degraded during a side impact vehicle crash.

Remedy

Dealers will inspect the welds on the left rear door upper hinge. If a weld is found out-of-specification, a bolt will be installed to secure the hinge. Owner notification began February 17, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Cadillac at 1-800-458-8006, Chevrolet at 1-800-222-1020, or GMC at 1-800-462-8782.

This recall on nhtsa.gov

Electrical system › 12V/24V/48V battery › Cables

Summary

Certain all-wheel drive sport utility vehicles were built without a power steering bracket to secure the positive battery cable, allowing the cable to come in contact with the steering shaft.

Consequence

This contact could cause a wear-through of the cable insulation, exposing the wire core and result in intermittent electrical shorting. If enough current is discharged at the point of contact, an engine compartment fire could occur.

Remedy

Dealers will inspect the positive battery cable routing and re-route, if necessary. No owner notification will take place since all vehicles were captured at the dealers.

This recall on nhtsa.gov