Skip to content
AnyRecalls

2007 Chevrolet Aveo recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

2 recalls found in NHTSA data as of September 22, 2026

For the 2007 Chevrolet Aveo. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Chevrolet been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Chevrolet dealer can also check your VIN. Recall repairs are free.

2007 Chevrolet Aveo recalls, newest first

May 19, 2014NHTSA 14V261000218,000 vehicles potentially affected

Exterior lighting › Headlights

Summary
General Motors is recalling certain model year 2004-2008 Chevrolet Aveo vehicles equipped with daytime running lights (DRL). In the affected vehicles, there may be heat generated within the DRL module located in the center console in the instrument panel, which could melt the DRL module.
Consequence
If the DRL module melts due to the heat generation, it could cause a vehicle fire.
Remedy
GM will notify owners, and dealers will install a revised DRL module, inspect the wiring connector for heat damage, and clean the DRL circuit grounds. Owners were sent interim notices on August 14, 2014. The recall began on February 6, 2015. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet). General Motors recall number for this campaign is 14236.

This recall on nhtsa.gov

October 17, 2006NHTSA 06V39800017,676 vehicles potentially affected

Fuel system, gasoline

Summary
On certain passenger vehicles equipped with a 1.6L engine, during a ncap severe frontal crash test, the fuel line in the engine compartment developed a fracture. In addition, the crash damage caused four short circuits in the fuse block, the combination of which allowed the fuel pump to continue running and fuel leaked onto the ground.
Consequence
If these conditions occurred in an actual crash, a vehicle fire could occur.
Remedy
Dealers will replace the fuse block and install a new section of fuel line that has been redesigned free of charge. The recall began on November 16, 2006. Owners may contact Chevrolet at 1-800-630-2438.

This recall on nhtsa.gov

Owner complaints

Owners have filed 216 complaints about the 2007 Chevrolet Aveo with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported
25
Fires reported
13
Injuries reported
25
Deaths reported
2

Most complained-about components

  1. Air bags63
  2. Electrical system47
  3. Exterior lighting29
  4. Service brakes16
  5. Engine13

Other Chevrolet Aveo years

Other 2007 Chevrolet models

Most recalled 2007 vehicles

  1. 2007 Ford E-350 (35 recalls)
  2. 2007 Freightliner Columbia (27 recalls)
  3. 2007 Ford E-250 (27 recalls)
  4. 2007 Thomas Built Buses SAF-T-Liner C2 (25 recalls)
  5. 2007 Thomas Built Buses Minotour (23 recalls)
All of 2007’s most recalled vehicles

Questions

Does the 2007 Chevrolet Aveo have any recalls?
2 recalls found in NHTSA data as of September 22, 2026, covering: exterior lighting, fuel system, gasoline. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2007 Chevrolet Aveo recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Chevrolet dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2007 Chevrolet Aveo?
216 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.