2004 Chevrolet Express recalls

Fuel system, gasoline › Storage › Tank assembly › Filler pipe and cap

Summary

General Motors (GM) is recalling certain model year 2003-2004 Chevrolet Express and GMC Savana vehicles, equipped with a left side cargo door, and originally sold or currently registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin, and the District of Columbia. Water and road contaminants may become trapped in the protective conduit that covers the fuel filler pipe and may cause the pipe to corrode.

Consequence

Significant corrosion may allow fuel to leak during refueling, and in the presence of an ignition source; there is an increased risk of fire.

Remedy

GM will notify owners, and dealers will install a new fuel filler neck, free of charge. The safety recall began on October 1, 2012. Owners may contact the Chevrolet owner center at 1-866-694-6546 and GMC at 1-866-996-9463.

This recall on nhtsa.gov

Exterior lighting

• Aftermarket equipment: applies only if this part was installed

Summary

Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.

Consequence

Decreased lighting visibility may result in a vehicle crash.

Remedy

Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.

This recall on nhtsa.gov

Seat belts

Summary

On certain full-size passenger, cargo, or cutaway vans, the front and rear seat belt buckles will not latch or will not unlatch.

Consequence

In the event of a crash, a seat occupant may not be properly restrained increasing the risk of personal injury.

Remedy

Dealers will inspect the buckles and, if found to be inoperative, the entire buckle assembly would be replaced. For buckles found to be operative, dealer will replace only the upper buckle cover. The recall will be conducted in phases. The first phase mailing began during March 2006. Owners may contact Chevrolet at 1-800-630-2438 or GMC at 1-866-996-9463.

This recall on nhtsa.gov

Service brakes, hydraulic

Summary

Certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions.

Consequence

If a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. The presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. The loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning.

Remedy

Dealers will test the hydro-boost assembly for functional operation of the two-function valve. If the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. The recall began on March 23, 2005. Owners may contact Chevrolet at 1-800-630-2438, GMC trucks at 1-866-996-9463 and hummer at 1-800-732-5493.

This recall on nhtsa.gov

Power train › Automatic transmission › Lever and linkage › Column shift

Summary

Certain vans were built with a transmission shift cable assembly that may separate. If the cable assembly separates, the transmission shift lever position and the transmission indicator may no longer correlate.

Consequence

If this were to occur, the vehicle could move in a direction not anticipated by the driver, which could result in a vehicle crash.

Remedy

Dealers will inspect the transmission shift cable assembly, and if necessary, replace it. The recall began on August 19, 2004. Owners should contact Chevrolet at 1-800-630-2438 or GMC at 1-866-996-9463.

This recall on nhtsa.gov

Seat belts › Front › Buckle assembly

Summary

Certain vans fail to conform to the requirements of federal motor vehicle safety standard no. 209, "seat belt assemblies." these vehicles may have been produced with seat belt buckle assemblies containing a latch with a brittle condition that may not withstand the force requirements of the standard.

Consequence

The safety belt may not restrain the occupant as intended during a crash, which could result in injury to the occupant.

Remedy

Dealers will replace the safety belt buckle. The recall beagn may 7, 2004. Owners should contact Chevrolet at 1-800-630-2438 or GMC at 1-866-996-9463.

This recall on nhtsa.gov

Service brakes, hydraulic

Summary

Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? Some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore.

Consequence

Consequently, the valve o-ring seal may fracture. Steering efforts may be slightly increased while braking or parking. Under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture.

Remedy

Dealers are to replace the hydro-boost relief valve. The recall began on June 18, 2004. Owners should contact Cadillac at 1-866-982-2339; Chevrolet at 1-800-630-2438; GMC at 1-866-996-9463; or hummer at 1-866-486-6376.

This recall on nhtsa.gov