2003 Chevrolet Venture recalls

Steering

• Aftermarket equipment: applies only if this part was installed

Summary

Dorman is recalling 979 steering knuckles, dorman p/nos. 697-902 and 697-903, sold under dorman's "oe solutionstm" brand name, and napa p/nos. 7-8502 and 7-8503 which were sold for replacement use on the various vehicles listed above. A potential material or design defect could result in the steering knuckle breaking in the hub area.

Consequence

A broken steering knuckle could result in loss of steering control and a possible crash without warning.

Remedy

Dorman will notify owners and replace the defective steering knuckles free of charge and reimburse the repair facility or owner for labor. The recall began on February 23, 2009. Owners may contact dorman's toll-free hotline at 1-800-523-2492 and press 5.

This recall on nhtsa.gov

Exterior lighting › Headlights

• Aftermarket equipment: applies only if this part was installed

Summary

K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. These headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."

Consequence

Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.

Remedy

K2 motor will notify owners and offer a full refund. The recall began on decemeber 17, 2008. Owners may contact K2 motor at 1-909-839-2992.

This recall on nhtsa.gov

Fuel system, gasoline › Storage

Summary

On certain vehicles, variations in the manufacturing process or exposure to high ambient temperatures may lead to fracture of the fuel tank inlet check valve (icv).

Consequence

A fracture may allow fuel vapors to pass through and allow droplets of fuel to accumulate on the side of the fuel tank. Fuel leakage, in the presence of an ignition source, could result in a fire.

Remedy

Dealers will replace the fuel tank. The recall will be mailed in two phases with the first phase beginning on December 4, 2007. The second phase will be mailed on December 13, 2007. Owners may contact Buick at 1-866-608-8080; Chevrolet at 1-800-630-2438; or Pontiac at 1-800-620-7668. The vehicle population includes Buick rendezvous and Pontiac aztek vehicle built in may 2003; Chevrolet venture and Pontiac montana vehicles built from June through August 2002; and all vehicles registered in nevada, arizona, virgin islands, puerto rico, and hawaii.

This recall on nhtsa.gov

Fuel system, other › Storage › Tank assembly › Pressure relief devices

• Aftermarket equipment: applies only if this part was installed

Summary

Certain delphi fuel pressure regulators, p/nos. FP10020-11B1, FP10026-11B1, and FP10027-11B1, sold after January 9, 2007, as aftermarket equipment for various passenger vehicles listed above. The universal pressure regulators (upr) were produced without an o'ring and retainer.

Consequence

Fuel may leak, possibly resulting in a fire.

Remedy

Delphi will notify owners and replace the upr free of charge. The recall began on April 23, 2007. Owners can contact delphi at 877-411-8770.

This recall on nhtsa.gov

Latches/locks/linkages › Doors › Latch

Summary

On certain minivans equipped with second-row bucket seats or captain's chairs and a power sliding door on the passenger side of the vehicle, a passenger using the interior handle to open the power sliding door could be injured.

Consequence

If a passenger uses the interior handle to open the power sliding door and holds onto the handle while it is being opened by the motor, the passenger's arm may be pushed into the seat back or armrest and a wrist or lower arm injury may result.

Remedy

Dealers will replace the power sliding door interior handle on the passenger-side. If the vehicle is equipped with a power or manual sliding door on the driver-side, the interior handle will also be replaced for appearance reasons. Note: before the vehicle is serviced, GM advises owners to not use the interior door handle to open the door. The driver can open and close the door from switches at the driver's position or by using the remote key fob. The driver should tell passengers to use the switch located in front of the door to open or close it. The driver should use the override switch to prevent operation of the power door by children or by others who are not familiar with its use. The owner notification letter mailing will be conducted in phases with the first phase beginning on may 31, 2005. The second phase mailing began on July 18, 2005. The recall began on may 31, 2005. Phase 2 began on July 18, 2005. Phase 3 (final phase) began on August 24, 2005, to all remaining customers. Owners should contact Chevrolet at 1-800-630-2438; Pontiac at 1-800-620-7668; or Oldsmobile at 1-800-630-6537.

This recall on nhtsa.gov

Equipment › Other › Owners/service/other manual

Summary

Certain minivans, passenger and sport utility vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage system." the owner's manual does not explain the meaning of the location symbols for the child restraint lower universal anchorage system.

Consequence

This does not meet the requirements of the standard.

Remedy

Owners will be provided with a supplement for their owner's manual. This supplement describes and shows the location symbols for the child restraint anchors that are located in the vehicle and on the child restraint or booster cushion. Owner notification began August 18, 2003. Owners should contact Buick at 1-866-608-8080, Cadillac at 1-866-982-2339, Chevrolet at 1-800-630-2438, GMC at 1-866-996-9463, Pontiac at 1-800-620-7668, or Oldsmobile at 1-800-630-6537.

This recall on nhtsa.gov

Air bags › Frontal › Driver side › Inflator module

Summary

On certain mini vans, passenger and sport utility vehicles, some of these vehicles have a driver's side air bag that may not deploy as designed. In addition, the air bag inflator could rupture.

Consequence

This could result in reduced capability of the air bag to protect the driver. Also if the air bag inflator ruptured, pieces of the inflator could strike and injure the vehicle occupants.

Remedy

Dealers will inspect, and if necessary, install a new driver's air bag. Owner notification began on March 11, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Buick at 1-800-521-7300, Cadillac at 1-800-458-8006, Chevrolet at 1-800-222-1020, GMC at 1-800-462-8782, or Pontiac at 1-800-762-2737.

This recall on nhtsa.gov

Air bags › Frontal

Summary

Certain passenger, mini vans, and sport utility vehicles have an air bag inflator on the driver's side that could fracture at a weld during a deployment.

Consequence

Pieces of the inflator could strike and injure vehicle occupants and the air bag cushion would not inflate fully, reducing the capability of the bag to protect the driver.

Remedy

Dealers will inspect, and replace, if necessary, the air bag module assembly on the driver's side. Owner notification began August 15, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Buick at 1-800-521-7300, Cadillac at 1-800-458-8006, Chevrolet at 1-800-222-1020, GMC at 1-800-462-8782, Oldsmobile at 1-800-442-6537, or Pontiac at 1-800-762-2737.

This recall on nhtsa.gov