Skip to content
AnyRecalls

2005 Coachmen Cross Country recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

4 recalls found in NHTSA data as of September 22, 2026

For the 2005 Coachmen Cross Country. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Coachmen been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Coachmen dealer can also check your VIN. Recall repairs are free.

2005 Coachmen Cross Country recalls, newest first

December 4, 2008NHTSA 08V63900013,662 vehicles potentially affected

Equipment › Recreational vehicle/trailer

Summary
Coachmen is recalling 13,662 my 2002-2008 motor homes, fifth wheel and travel trailers equipped with glass shower doors and manufactured from June 15, 2001 thorugh August 6, 2007. When pressure is applied to the towel bar on the glass shower door, the edge of the bar may contact the glass.
Consequence
Glass breakage may occur which could cause personal injury.
Remedy
Owners will be provided with new mounting hardware for the towel bar and installation instructions. If an owner is not comfortable replacing the hardware themselves, a dealer will install the hardware at no cost to them. The recall is expected to begin on or about December 19, 2008. Owners may contact coachmen at 1-574-825-5821.

This recall on nhtsa.gov

June 25, 2008NHTSA 08V27900037,293 vehicles potentially affected

Equipment › Recreational vehicle/trailer

Summary
Coachmen is recalling 37,293 motorhomes and fifth wheel travel trailers equipped with a two-door refrigerator manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
Consequence
Extended operation of a leaking cooling unit could lead to a fire from gas which might escape.
Remedy
Coachmen is working with dometic in order to repair these refrigerators (please see 08E032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle Inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1-888-446-5157 or coachmen at 574-825-5821.

This recall on nhtsa.gov

April 28, 2008NHTSA 08V193000961 vehicles potentially affected

Steering › Hydraulic power assist system

Summary
Coachmen is recalling 961 my 2005-2007 cross country, sportscoach elite, my 2005-2006 cross country se, and my 2006 sportscoach encore class a motor homes built using inline power steering filters, part no. 14-16829-000. The filter can plug due to failure of the screen adhesion to the filter housing causing a rise in return line pressure. This can lead to hose separation from the filter or steering gear fitting resulting in a sudden loss of steering fluid and power assist.
Consequence
Sudden loss of steering assist without warning involving a motor home could be a problem for certain drivers increasing the risk of a crash.
Remedy
Coachmen is working with freightliner to replace the affected filters with a larger filter (please see 07V570). Owners may contact freightliner at 1-800-547-0712 or coachmen at 1-574-825-5821.

This recall on nhtsa.gov

June 21, 2005NHTSA 05V294000135 vehicles potentially affected

Electrical system

Summary
On certain rear diesel motor homes containing a 50 amp transfer switch built by intellitec, the material used for the wire lugs was changed from nickel plated to copper lugs. The copper lugs are softer than the nickel plated and do not retain the torque of the screw that clamps the wire connector.
Consequence
When the torque is relaxed, the lugs can become loose resulting in excessive heat within the connected wire that could result in a fire.
Remedy
Coachmen will be working with intellitec to notify owners and have the repair performed on their vehicles. The recall began on July 14, 2005. Owners may contact coachmen at 1-574-825-1174.

This recall on nhtsa.gov

Owner complaints

Owners have filed 1 complaint about the 2005 Coachmen Cross Country with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported
0
Fires reported
0
Injuries reported
0
Deaths reported
0

Most complained-about components

  1. Electrical system1
  2. Visibility › Windshield wiper/washer1

Other Coachmen Cross Country years

Other 2005 Coachmen models

Most recalled 2005 vehicles

  1. 2005 Honda Accord (24 recalls)
  2. 2005 Ford E-350 (16 recalls)
  3. 2005 IC CE (16 recalls)
  4. 2005 Thomas Built Buses SAF-T-Liner C2 (16 recalls)
  5. 2005 Honda Pilot (15 recalls)
All of 2005’s most recalled vehicles

Questions

Does the 2005 Coachmen Cross Country have any recalls?
4 recalls found in NHTSA data as of September 22, 2026, covering: equipment, steering, electrical system. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2005 Coachmen Cross Country recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Coachmen dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2005 Coachmen Cross Country?
1 complaint filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.