Skip to content
AnyRecalls

2005 Girardin MB IV recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

9 recalls found in NHTSA data as of September 22, 2026

For the 2005 Girardin MB IV. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Girardin been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Girardin dealer can also check your VIN. Recall repairs are free.

2005 Girardin MB IV recalls, newest first

August 13, 2010NHTSA 10V377000130 vehicles potentially affected

Equipment

Summary
Certain girardin model year 2006 through 2010 and micro bird by girardin model year 2009 through 2010 G5 and 2003 through 2006 girardin mb IV transit buses fail to conform to the requirements of federal motor vehicle safety standard no. 217, "bus emergency exists and window retention and release." the vehicles are equipped with thermal t-slider or panoramic type push-out windows with 2 release mechanisms (one on each side). The window handle base spacer plate can tear due to the rotation of the exterior window frame.
Consequence
In the event of a crash, the emergency exit could not sufficiently restrain the occupant(s) or become inoperable. The occupant(s) could be thrown from the vehicle or not be capable of opening the emergency exits which could cause injury or death of the vehicle occupant(s).
Remedy
Girardin will notify owners and will provide parts to perform the repair along with instructions free of charge. The safety recall began on October 8, 2010. Owners may contact micro bird at 1-819-477-2012.

This recall on nhtsa.gov

December 14, 2007NHTSA 07V574000640 vehicles potentially affected

Electrical system › 12V/24V/48V battery › Cables

Summary
Certain my 2004 through 2008 girardin mb II and mb IV school and commercial minibuses manufactured between April 14, 2004, and November 28, 2007, built on Ford E350 and E450 diesel chassis. The affected buses are equipped with option bbx (battery box). The protection from abrasion on the battery cables that cross in the battery box is inadequate. It may create a short circuit in case the abrasion between the cables is excessive.
Consequence
This short circuit could result in a fire.
Remedy
Girardin will notify owners and repair the buses by adding protective tubes free of charge. The recall began on January 7, 2008. Owners can contact girardin at 819-477-8222.

This recall on nhtsa.gov

December 13, 2007NHTSA 07V56500033 vehicles potentially affected

Equipment adaptive/mobility

Summary
Certain my 2005 and 2006 mb II and mb IV school and commercial buses manufactured between July 2005 and June 2006, on Ford and GM chassis with 6.6L engines equipped with braun lift models NL916, NL917, and NL919. The threshold warning system may not activate as designed which fails to conform to federal motor vehicle safety standard no. 404, platform lift installations for motor vehicles.
Consequence
Should the threshold warning system fail to operate, the lift user can fall from the vehicle and be seriously injured.
Remedy
Owners will be notified by girardin instructing them to contact braun for free repair. The recall began on March 18, 2008. Owners can contact braun product support at 1-800-946-7513 or girardin minibus service and warranty department at 819-477-8222.

This recall on nhtsa.gov

April 24, 2006NHTSA 06V13300013 vehicles potentially affected

Equipment adaptive/mobility

Summary
Certain girardin my 2005 and 2006 mb IV school and commercial buses and 2006 mb II school buses manufactured between June 29, 2005, and may 10, 2006, and equipped with ricon k-series wheelchair lifts, p/n K5505-F1020000A & K2010-F1020000A. The welding process may not have achieved full penetration along the seam of the vertical arms. Improperly welded vertical arms will not allow the lift to stow properly.
Consequence
In the event this condition occurs during passenger operations it may not be possible to close the lift door causing the vehicle interlocks to remain engaged preventing movement of the vehicle or the ability to load or unload passengers with disabilities from the vehicle.
Remedy
Ricon is conducting this recall (please see 06E008000) and will replace the two vertical arms even if only one arm is cracked free of charge. The recall is expected to begin during may 2006. Owners may contact ricon customer support dept. At 800-322-2884 or owners may contact girardin at 819-477-8222.

This recall on nhtsa.gov

February 2, 2006NHTSA 06V02700013 vehicles potentially affected

Equipment

Summary
Certain girardin 2004 and 2005 mb IV school and commercial buses manufactured between July 6, 2004, and February 10, 2005, equipped with carrier compressor mount brackets, p/n 86-62400-00. This weld is used to mount the secondary compressor for the supplemental air conditioning system on to the engine. If the installer does not adequately torque the mounting hardware or there is a poor quality weld at the weldment's support tab, the weldment can break or fall off.
Consequence
If the weldment breaks or falls off, the compressor and vacuum pump could shift causing the misalignment and eventual loss of the drive belt, possibly resulting in the loss of or impedance to the vehicle's primary braking system, and could potentially cause a vehicle crash.
Remedy
Owners are being instructed to contact carrier at 717-767-3359 or visit their website at www.transicold.carrier.com for free remedy. The recall began on February 15, 2006. Owners may also contact girardin minibus service and warranty department at 819-477-8222.

This recall on nhtsa.gov

August 22, 2005NHTSA 05V36500010 vehicles potentially affected

Structure › Body › Roof and pillars

Summary
Certain 2003 through 2005 girardin mb II and mb IV school buses manufactured between August 17 and October 29, 2004. The amount of adhesive applied to the roof seams and interior panels is inadequate for the type of adhesive used which fails to comply with the requirements of federal motor vehicle safety standard no. 221, school bus body joint strength. Also, due to the inadequate joint strength, these buses fail to conform to the seat test requirements of federal motor vehicle safety standard no. 210, seat belt assembly anchorages.
Consequence
In the event of a vehicle crash, the affected panels and seats may not resist and this could possibly endanger the vehicle occupants.
Remedy
Girardin will notify its owners and repair the buses free of charge. The recall began on November 3, 2003. Owners may contact girardin at 1-819-477-8222.

This recall on nhtsa.gov

August 4, 2005NHTSA 05V3520001,498 vehicles potentially affected

Other › School bus stop arm assembly

Summary
Certain girardin my 2002 through 2005 mb II & mb IV school buses manufactured between January 1, 2002, and August 8, 2005, and equipped with "5" series stop arms manufactured by specialty manufacturing company. In extremely cold weather, the microswitches used internally to position the sign in the open and closed positions may malfunction, causing the sign to open or close in an improper position, or to not open at all.
Consequence
Should the stop arm not perform properly, a child or pedestrian may be endangered by passing vehicles should the motorist not stop at the correct location.
Remedy
Girardin will notify owners and replace the original switch with a switch pack that is not sensitive to extreme cold weather and will inspect to ensure the microswitch heater wiring is properly connected free of charge. The recall began on August 22, 2005. Owners may contact girardin at 1-800-951-7867.

This recall on nhtsa.gov

April 7, 2005NHTSA 05V141000204 vehicles potentially affected

Seats

Summary
Certain my 2003-2005 girardin mb II and mb IV school buses manufactured between March 20, 2003, and December 16, 2004, (see amended noncompliance report received August 18, 2005) built on Ford and GM chassis. Seats equipped with the child seat anchorage system fails to conform to federal motor vehicle safety standard no. 222, 'school bus passenger seating and crash protection.'
Consequence
The seat back may not absorb enough energy in the event of a vehicle crash, possibly resulting in serious injury or death to the seat occupant.
Remedy
Girardin will notify its customers and install a flat bar on each side of the seat where the child seat anchorage is bolted to increase the strength of the seat back free of charge. The recall began on April 19, 2005. Owners may contact girardin at 819-477-8222.

This recall on nhtsa.gov

January 24, 2005NHTSA 05V012000121 vehicles potentially affected

Electrical system › 12V/24V/48V battery › Cables

Summary
Certain girardin minibus my 2004 and 2005 mb II and mbiv Ford diesel school buses equipped with optional bbx (battery box) manufactured between may 14, 2004 and February 9, 2005. The electrical cables (p/nos. 27DF01 and 27DF3001) between the batteries and the battery junction box (under the hood) has no fusable link for cable protection.
Consequence
There is no protection on the electrical cable and if there is a short circuit, it may possibly result in a fire.
Remedy
The manufacturer will notify its customers and install a fusable link at the end of the cable attached to the battery free of charge. The recall began on February 25, 2005. Owners may contact girardin at 819-477-8222.

This recall on nhtsa.gov

Owner complaints

No owner complaints about the 2005 Girardin MB IV were found in NHTSA’s complaint data.

Other Girardin MB IV years

Other 2005 Girardin models

Most recalled 2005 vehicles

  1. 2005 Honda Accord (24 recalls)
  2. 2005 Ford E-350 (16 recalls)
  3. 2005 IC CE (16 recalls)
  4. 2005 Thomas Built Buses SAF-T-Liner C2 (16 recalls)
  5. 2005 Honda Pilot (15 recalls)
All of 2005’s most recalled vehicles

Questions

Does the 2005 Girardin MB IV have any recalls?
9 recalls found in NHTSA data as of September 22, 2026, covering: equipment, electrical system, equipment adaptive/mobility, structure, other, seats. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2005 Girardin MB IV recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Girardin dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2005 Girardin MB IV?
0 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.