Skip to content
AnyRecalls

2003 Gulf Stream Sun Voyager recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

8 recalls found in NHTSA data as of September 22, 2026

For the 2003 Gulf Stream Sun Voyager. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Gulf Stream been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Gulf Stream dealer can also check your VIN. Recall repairs are free.

2003 Gulf Stream Sun Voyager recalls, newest first

November 22, 2010NHTSA 10V5840001,328 vehicles potentially affected

Equipment › Recreational vehicle/trailer

Summary
Gulf stream is recalling certain recreational vehicles and fifth wheel trailers equipped with 1200-series norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.
Consequence
The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak may not shut off in sufficient time to prevent a fire.
Remedy
Gulf stream is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10E-049 for additional information. The recall began on March 23, 2011. Owners may contact norcold at 1-800-767-9101 or gulf stream at 1-574-773-7761.

This recall on nhtsa.gov

October 1, 2009NHTSA 09V382000242 vehicles potentially affected

Equipment

Summary
Gulf stream is recalling certain motorhomes equipped with norcold model 1200LR, 1200LRIM, and 1201LRIM refrigerators with serial numbers between 1273701 and 1536607, non-consecutively. A fatigue failure in the section of the cooling unit which contains the refrigerant could allow the liquid solution to slowly leak. If a leak occurs and the refrigerator continues to be operated after solution circulation has ceased the heat source could generate very high temperatures. At such high temperatures, the cooling unit could rupture.
Consequence
If a leak occurs and the unit continues to operate, hydrogen gas may be expelled and can be ignited, resulting in a fire, possibly causing serious injury or death.
Remedy
Gulf stream is working with norcold and the vehicle's refrigerator will be repaired free of charge. Please also see norcold's defect notice 09E-027. The safety recall began on October 20, 2009. Owners may contact gulf stream at 1-800-289-8787 or norcold's recall center at 1-800-767-9101.

This recall on nhtsa.gov

July 1, 2009NHTSA 09V24500015 vehicles potentially affected

Service brakes, hydraulic

Summary
Gulf stream is recalling 15 motorhomes equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag.
Consequence
The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.
Remedy
Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy and owner notification for this campaign please see 09V-110. Owners may contact workhorse at 1-877-246-7731

This recall on nhtsa.gov

August 15, 2008NHTSA 08V41100026,847 vehicles potentially affected

Equipment › Recreational vehicle/trailer

Summary
Gulf stream is recalling 26,847 my 2003-2006 recreational vehicles equipped with a two-door refrigerator manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
Consequence
If this solution is exposed to an ignition source under certain specific circumstances, it can result in a vehicle fire.
Remedy
Gulf stream is working with dometic to repair these refrigerators (please see 08E032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle Inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1-888-446-5157 or gulf stream at 1-574-773-7761.

This recall on nhtsa.gov

March 20, 2007NHTSA 07V13600038,767 vehicles potentially affected

Equipment › Recreational vehicle/trailer

Summary
Certain motor homes, fifth wheel and travel trailers equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
Consequence
Release of coolant under certain conditions could ignite and result in a fire.
Remedy
Gulf stream will be working with dometic in order to repair these refrigerators (please see 06E076). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle Inc. To manage this campaign. Stericycle will assist you in locating dealerships or service centers and will provide assistance with scheduling of appointments. The recall began on June 28, 2007. Owners may contact dometic/stericycle at 1-888-446-5157 or gulf stream at 1-574-773-7761.

This recall on nhtsa.gov

April 11, 2006NHTSA 06V113000995 vehicles potentially affected

Electrical system

Summary
Certain motor homes built on workhorse chassis and equipped with actia corporate instrument clusters fail to comply with the requirements of federal motor vehicle safety standard nos. 101 "controls and displays" and 105 "hydraulic and electric brake systems." if the brake fail input falls below a voltage of 1.5V, the brake failure lamp and alarm will be activated. Also activation of the ABS telltale when the ABS is not properly functioning does not always occur.
Consequence
At night the instrument cluster lights may fail and the driver may not be able to see the instrument panel gauges and the brake warning light indicator which could increasing the risk of a crash.
Remedy
Workhorse is conducting the owner notification and remedy for this campaign and reprogram the instrument panel cluster free of charge. Owners may contact workhorse at 1-877-246-7731 or gulf stream at 574-773-7761.

This recall on nhtsa.gov

September 3, 2003NHTSA 03V33000063 vehicles potentially affected

Trailer hitches

Summary
On certain motor homes built on the workhorse W22 chassis, the drop down brackets used to attach the hitch to the frame rail extensions may not be adequate.
Consequence
In the event that these angle brackets would fail, the hitch and the tow vehicle could become dislodged from the motor home increasing the risk of a crash.
Remedy
Gulf stream has developed a repair kit consisting of steel brackets, spacers, and mechanical fasteners. This kit can be sent directly to you or to a repair facility of your choosing. Owner notification is expected to begin during September 2003. Owners should contact gulf stream at 1-800-482-6456, ext. 3743.

This recall on nhtsa.gov

March 12, 2003NHTSA 03V092000998 vehicles potentially affected

Service brakes, hydraulic › Brake fluid low warning › Lamp

Summary
Certain motor home chassis fail to comply with the requirements of federal motor vehicle safety standard no. 105, "hydraulic and electric brake systems." the brake system warning indicator may not function as required by standard.
Consequence
In some of the affected vehicles, the brake system warning indicator will not illuminate when the ignition is in the start position or for a low brake fluid condition, if the body builder relied solely upon Ford's ivm compliance statement for the brake system warning indicator.
Remedy
Dealers will repair the brake warning lamp circuit. Owner notification is began may 1, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact gulf stream at 1-574-773-7761.

This recall on nhtsa.gov

Owner complaints

Owners have filed 6 complaints about the 2003 Gulf Stream Sun Voyager with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported
0
Fires reported
1
Injuries reported
0
Deaths reported
0

Most complained-about components

  1. Service brakes4
  2. Air › Antilock › ABS warning light1
  3. Equipment › Recreational vehicle/trailer1
  4. Hydraulic1
  5. Hydraulic › Antilock/traction control/electronic limited slip1

Other Gulf Stream Sun Voyager years

Other 2003 Gulf Stream models

Most recalled 2003 vehicles

  1. 2003 Honda Accord (24 recalls)
  2. 2003 Honda Civic (24 recalls)
  3. 2003 Honda Odyssey (15 recalls)
  4. 2003 Subaru Outback (15 recalls)
  5. 2003 Subaru Legacy (15 recalls)
All of 2003’s most recalled vehicles

Questions

Does the 2003 Gulf Stream Sun Voyager have any recalls?
8 recalls found in NHTSA data as of September 22, 2026, covering: equipment, service brakes, hydraulic, electrical system, trailer hitches. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2003 Gulf Stream Sun Voyager recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Gulf Stream dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2003 Gulf Stream Sun Voyager?
6 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.