Does the 2002 Mitsubishi Fuso FE640 have any recalls?

7 recalls found in NHTSA data as of September 22, 2026, covering: exterior lighting, power train, engine and engine cooling, fuel system, gasoline. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.

How do I check if my 2002 Mitsubishi Fuso FE640 recall has been fixed?

Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Mitsubishi Fuso dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.

How many complaints have owners filed about the 2002 Mitsubishi Fuso FE640?

0 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.

2002 Mitsubishi Fuso FE640 recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

7 recalls found in NHTSA data as of September 22, 2026

For the 2002 Mitsubishi Fuso FE640. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Mitsubishi Fuso been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

Check your VIN with NHTSA

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Mitsubishi Fuso dealer can also check your VIN. Recall repairs are free.

2002 Mitsubishi Fuso FE640 recalls, newest first

March 30, 2009NHTSA 09E010000156 vehicles potentially affected

Exterior lighting › Headlights

Aftermarket equipment: applies only if this part was installed

Summary: Mitsubishi fuso truck of america (mfta) is recalling 156 halogen sealed beam high beam headlamp assemblies sold between October 24, 2007 and December 2, 2008 for use as replacement equipment for certain Mitsubishi fuso trucks. These lamps fail to conform to the sae standards or recommended practices referenced in table I of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence: The purpose of this standard is to reduce deaths and injuries from motor vehicle crashes by providing adequate illumination of the roadway.
Remedy: Mfta will notify owners and replace the headlamps free of charge. The safety recall began on April 15, 2009. Owners may contact mfta at 1-856-467-4500.

This recall on nhtsa.gov

May 16, 2008NHTSA 08V22400015,549 vehicles potentially affected

Power train › Automatic transmission

Summary: Mitsubishi fuso is recalling 15,549 my 1999-2004 FE639, FE649, and FG639 trucks; my 2001-2004 FE640, and my 2003-2004 FH210 trucks equipped with automatic transmissions. Normal heat emanating from the exhaust pipe may cause the automatic transmission shift linkage to deform. The effort required to operate the automatic transmission shift control lever may increase if the linkage binds due to the deformation.
Consequence: The shift control lever may become inoperative, or the physical shift lever position on the shift lever housing gear indicator may not match the actual gear selection at the transmission.
Remedy: Dealers will install a modified automatic transmission shift control lever assembly free of charge. The recall began on August 6, 2008. Owners may contact Mitsubishi fuso at 1-856-467-4500.

This recall on nhtsa.gov

March 26, 2007NHTSA 07V1380008,712 vehicles potentially affected

Engine and engine cooling

Summary: On certain trucks, the cylinder head idler gear bushing may have been improperly machined, causing excessive stress on the cylinder head idler gear shaft. Continued operating in this condition could cause the idler gear shaft flange to break and generate abnormal engine noise or engine oil leaks.
Consequence: The engine could stall and would not restart increasing the risk of a crash.
Remedy: On vehicles with less than 15,000 miles, if the idler gear and bushing assembly, idler gear shaft and bolt will be replaced. If the mileage is more than 15,000 miles, the inside diameter of the idler gear bushing will be measured and if the bushing measures more than 32.043MM (1.262"), the idler gear and bushing assembly, idler gear shaft and bolt will be replaced. The recall began on August 13, 2007. Owners may contact Mitsubishi fuso at 1-856-467-4500.

This recall on nhtsa.gov

October 4, 2005NHTSA 05V4510001,848 vehicles potentially affected

Engine and engine cooling

Summary: On certain medium duty trucks, the cylinder head idler gear shaft bolt may have been insufficiently tightened during initial assembly. Continued operation in this condition could cause the bolt to loosen, resulting in abnormal noise from improper gear alignment.
Consequence: The bolt could break, causing the engine to stall and not restart, increasing the risk of a crash.
Remedy: Dealers will check the idler shaft bolt. If the bolt cannot be removed by hand, a modified idler shaft bolt will be installed. If the bolt is loose enough to be removed by hand, a new idler gear, idler shaft, and a modified idler shaft bolt will be installed. The recall began on December 20, 2005. Owners may contact Mitsubishi fuso at 1-856-467-4500.

This recall on nhtsa.gov

June 29, 2005NHTSA 05V30400015,549 vehicles potentially affected

Power train › Automatic transmission › Lever and linkage › Floor shift

Summary: On certain medium duty trucks, rust build-up on the automatic transmission (a/t) shift linkage may cause the linkage to bind. Rust build-up is accelerated in geographic locations that are situated near large bodies of salt water, or in regions with heavy snow/ice melting compound usage in winter months.
Consequence: The effort required to operate the a/t shift control lever may increase if the linkage binds due to rust build-up. The shift control lever may become inoperative, or the physical shift lever position on the shift lever housing gear indicator may not match the actual gear selection at the transmission.
Remedy: Dealers will install a modified a/t shift control lever assembly. The recall began on September 26, 2005. Owners may contact Mitsubishi fuso at 1-856-467-4500.

This recall on nhtsa.gov

June 29, 2005NHTSA 05V30300015,307 vehicles potentially affected

Engine and engine cooling

Summary: On certain medium duty trucks, the rear engine support bracket is composed of materials of insufficient strength. Normal vehicle vibrations may cause the bracket to crack.
Consequence: If the vehicle is continually operated in this condition, the bracket may break apart, causing the transmission to drop out of alignment with the drive train.
Remedy: Dealers will install a modified rear engine support bracket. The recall began on September 26, 2005. Owners should contact Mitsubishi fuso at 1-856-467-4500.

This recall on nhtsa.gov

December 3, 2004NHTSA 04V5700003,674 vehicles potentially affected

Fuel system, gasoline › Fuel injection system

Summary: On certain trucks, the rubber portion of the fuel injection pipe clamps could deteriorate. Normal vehicle operation could cause the deteriorated clamp to loosen and drip.
Consequence: If this condition occurs in the area of the fuel injection pump, the engine starter could short circuit if the clamp drops onto the starter terminal. This could prevent the engine from starting. Excessive heat from the short circuit could cause a fire.
Remedy: Dealers will remove each clamp and inspect for rubber deterioration and will replace the clamp if the rubber deterioration is evident. Dealers will replace the attaching hardware and apply adhesive to prevent the bolts/nuts from loosening and inspect for a rubber cap on the starter motor's terminal and install a cap if one is not present to prevent a short circuit. The recall began on January 13, 2005. Owners should contact Mitsubishi fuso at 1-877-711-0707.

This recall on nhtsa.gov

Owner complaints

No owner complaints about the 2002 Mitsubishi Fuso FE640 were found in NHTSA’s complaint data.

Other Mitsubishi Fuso FE640 years

Other 2002 Mitsubishi Fuso models

Most recalled 2002 vehicles

2002 Honda Civic (24 recalls)
2002 Jeep Grand Cherokee (16 recalls)
2002 Honda Accord (16 recalls)
2002 Honda CR-V (16 recalls)
2002 Chevrolet Silverado (15 recalls)

All of 2002’s most recalled vehicles

Questions

Does the 2002 Mitsubishi Fuso FE640 have any recalls?: 7 recalls found in NHTSA data as of September 22, 2026, covering: exterior lighting, power train, engine and engine cooling, fuel system, gasoline. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2002 Mitsubishi Fuso FE640 recall has been fixed?: Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Mitsubishi Fuso dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2002 Mitsubishi Fuso FE640?: 0 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.