Equipment recall 08E026000 · March 27, 2008

2005-2008 Ford F-250 SD

Compressive forces of the welded lift blocks resulting from foreseeable and excess vehicle payloads as well as over-tightening of the u-bolts during installation may distort the…

This is a recall of aftermarket equipment listed for the vehicles below. It applies only if the recalled part was installed on the vehicle.

Summary

Truxxx is recalling 338 aftermarket replacement welded 3" lift blocks for rear suspensions, part no. 206073, included in suspension kit nos. 108035 and 108036, sold between July 26, 2007 and March 4, 2008, for use on Ford my 2005-2008 F-250 superduty 4X4 light trucks. Compressive forces of the welded lift blocks resulting from foreseeable and excess vehicle payloads as well as over-tightening of the u-bolts during installation may distort the blocks, reducing the intended clamping force of the u-bolts.

Consequence

This could allow possible shifting and damage to the rear drive shaft and axle.

Remedy

Truxxx will notify customers/installers and will replace affected welded lift blocks with either non-welded aluminum or cast iron blocks free of charge. The recall is expected to begin on or about April 16, 2008. Owners may contact truxxx at 1-800-381-8320.

Notes

Truxxx recall no. 08-01BLK.THIS recall only pertains to aftermarket suspension kits and has not relation to any original equipment installed on Ford motor company vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (TTY: 1-800-424-9153); or go to http://www.safercar.gov.