Skip to content
AnyRecalls

2016 Volvo VNL recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

6 recalls found in NHTSA data as of September 22, 2026

For the 2016 Volvo VNL. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

One of these recalls carries a manufacturer safety advisory to stop driving or to park outside until repaired. See below.

Has your Volvo been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Volvo dealer can also check your VIN. Recall repairs are free.

2016 Volvo VNL recalls, newest first

September 25, 2018NHTSA 18V6680003,705 vehicles potentially affected

Engine and engine cooling › Engine › Diesel

Summary
Volvo Trucks North America (Volvo) is recalling certain 2016-2019 Volvo VNL trucks equipped with Cummins ISX15 diesel engines. In certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted.
Consequence
If the fuel line bursts, fuel may leak onto the road resulting in a roadway hazard for other motorists. The engine may also stall without warning, resulting in the vehicle's inability to restart, increasing the risk of a crash.
Remedy
Cummins will notify owners, and dealers will replace the single screen filter banjo bolt will be replaced with a dual screen filter banjo bolt, free of charge. The recall began November 21, 2018. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1802.

This recall on nhtsa.gov

August 29, 2017NHTSA 17V536000470 vehicles potentially affected

Steering › Linkages › Tie rod assembly

Summary
Volvo Trucks North America (Volvo) is recalling certain 2016 Volvo VNL and VNM trucks equipped with certain Dana Spicer D-Series and E-Series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.
Consequence
If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering, increasing the risk of a crash.
Remedy
Volvo will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary. If the tie rod stud and knuckle on units cannot be sufficiently torqued, the dealer will replace the knuckle and tie rod end assembly, free of charge. The recall began on October 17, 2017. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1702.
Components
Steering › Linkages › Tie rod assembly; Steering

This recall on nhtsa.gov

December 22, 2016NHTSA 16V9280005,547 vehicles potentially affected

Service brakes, air

Summary
Volvo Trucks North America (Volvo) is recalling certain model year 2013-2017 VNL and VNM trucks and certain model year 2017 VNX trucks. In the affected vehicles, incorrect software for controlling the electronic air dryer may result in oil and water contaminating the brake system.
Consequence
If the brake system becomes contaminated, braking performance could be affected, increasing the risk of a crash.
Remedy
Volvo will notify owners, and dealers will reprogram the vehicle control module and replace the air dryer filter, free of charge. The recall began on February 16, 2017. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1608.

This recall on nhtsa.gov

February 19, 2016NHTSA 16V0950002,053 vehicles potentially affected

Suspension › Front › Control arm › Lower ball joint

Summary
Volvo Trucks North America (Volvo) is recalling certain model year 2009-2010 VT trucks manufactured from April 9, 2008, through September 24, 2009, and certain 2016 model VNL and VNM trucks manufactured from January 2, 2015, through to November 6, 2015. The affected vehicles are equipped with USK non-greasable drag links that may experience corrosion of the ball joints due to the seals being compromised, possibly resulting in accelerated wear and failure of the ball joint.
Consequence
Failure of the ball joint may cause separation of the socket and a complete loss of steering, increasing the risk of a crash.
Remedy
Volvo will notify owners, and dealers will replace the drag links, free of charge. The recall began on April 21, 2016. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1601. Note: This recall is an expansion of a previous recall 15V-651.
Components
Suspension › Front › Control arm › Lower ball joint; Suspension › Front › Control arm › Upper ball joint

This recall on nhtsa.gov

February 17, 2016NHTSA 16V09700018,116 vehicles potentially affected

Steering

  • Do not drive until repaired
Summary
Volvo Trucks North America (Volvo) is recalling certain model year 2016-2017 VNL, VNX, and VNM trucks manufactured from May 11, 2015, through April 18, 2016. The trucks may have been manufactured without a roll pin on the steering shafts. If the roll pin is missing, the lower steering shaft may disconnect from the junction block. Also, the bolt connecting the upper steering shaft to the lower steering shaft may not have been properly tightened. Either condition can lead to separation of the steering shaft.
Consequence
Separation of the steering shaft will result in complete loss of steering which may lead to a vehicle crash.
Remedy
Volvo is strongly recommending that the affected vehicles not be driven until the interim remedy is applied. An interim notice was sent to Volvo owners on March 16, 2016, and an interim repair is available now. A second notice was mailed on May 13, 2016. The final remedy is now available. Both remedies are free of charge. Owners may contact Volvo customer service at 1-877-800-4945 opt #1. Volvo's recall numbers for this campaign are RVXX1602 and RVXX1603. This recall supersedes safety recall 15V-786.

This recall on nhtsa.gov

January 22, 2015NHTSA 15V026000170 vehicles potentially affected

Parking brake › Driveline › Hydraulic › Actuator

Summary
Volvo Trucks North America (Volvo) is recalling certain model year 2015 and 2016 VNX and VNL trucks manufactured from May 20, 2014, through March 6, 2015, equipped with certain Haldex Life Seal Type 30/30 Long Stroke Air Brake Actuators manufactured January 9, 2014, to October 28, 2014. The affected actuators may have an incomplete attachment of the internal rubber diaphragm to the actuation mechanism of the parking brake section of the Life Seal actuator.
Consequence
If the diaphragm is not completely attached, there may be internal leakage from the service section past the diaphragm, potentially trapping air pressure in the parking brake section. This air pressure in turn, if not vented, may prevent full release of the actuator unit, and may induce brake drag and may result in overheated wheelend service brakes, increasing the risk of a fire.
Remedy
Volvo will notify owners, and dealers will inspect the brake actuator and replace, as necessary, free of charge. The recall began March 20, 2015. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX1501.

This recall on nhtsa.gov

Owner complaints

Owners have filed 12 complaints about the 2016 Volvo VNL with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported
2
Fires reported
0
Injuries reported
0
Deaths reported
0

Most complained-about components

  1. Power train6
  2. Service brakes2
  3. Suspension2
  4. Power train › Driveline › Driveshaft1
  5. Steering1

Other Volvo VNL years

Other 2016 Volvo models

Most recalled 2016 vehicles

  1. 2016 Thomas Built Buses SAF-T-Liner HDX (29 recalls)
  2. 2016 Blue Bird Vision (27 recalls)
  3. 2016 Altec Aerial Device (26 recalls)
  4. 2016 Thomas Built Buses SAF-T-Liner C2 (25 recalls)
  5. 2016 Autocar Xpeditor (22 recalls)
All of 2016’s most recalled vehicles

Questions

Does the 2016 Volvo VNL have any recalls?
6 recalls found in NHTSA data as of September 22, 2026, covering: engine and engine cooling, steering, service brakes, air, suspension, parking brake. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2016 Volvo VNL recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Volvo dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2016 Volvo VNL?
12 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.