Does the 2005 Chrysler PT Cruiser have any recalls?

5 recalls found in NHTSA data as of September 22, 2026, covering: exterior lighting, suspension, visibility, service brakes, hydraulic, steering. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.

How do I check if my 2005 Chrysler PT Cruiser recall has been fixed?

Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Chrysler dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.

How many complaints have owners filed about the 2005 Chrysler PT Cruiser?

187 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.

2005 Chrysler PT Cruiser recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

5 recalls found in NHTSA data as of September 22, 2026

For the 2005 Chrysler PT Cruiser. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Chrysler been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. Recall repairs are free.

2005 Chrysler PT Cruiser recalls, newest first

April 7, 2009NHTSA 09E01200016,270 vehicles potentially affected

Exterior lighting

Aftermarket equipment: applies only if this part was installed

Summary: Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence: Decreased lighting visibility may result in a vehicle crash.
Remedy: Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.

This recall on nhtsa.gov

April 14, 2008NHTSA 08E0330006,903 vehicles potentially affected

Suspension

Aftermarket equipment: applies only if this part was installed

Summary: Federal mogul is recalling 6,903 aftermarket ball joint assemblies shipped between November 9, 2007 and March 26, 2008, which may have been packaged with incorrect nuts. The part numbers packaged with incorrect nuts are: K7147, K7329, K8683, and 104353. These parts were made for use on the various vehicles listed above.
Consequence: The nuts included in the packaging for these ball joint assemblies are missing the intended prevailing torque (self-locking) feature. If the incorrect nut was to become loose, the joining members may loosen leading to a separation of the ball joint. This may result in loss of vehicle control, possibly resulting in a vehicle crash.
Remedy: Federal mogul will notify owners and replace the parts free of charge. The recall began on may 22, 2008. Owners can contact federal mogul at 877-489-6659.

This recall on nhtsa.gov

April 4, 2007NHTSA 07V14900038,447 vehicles potentially affected

Visibility › Glass, side/rear

Summary: On certain passenger vehicles, the rear quarter glass attaching fasteners may pull through their mounts and allow the glass to separate from the vehicle.
Consequence: If the glass separates while driving, it could strike another vehicle or injure a pedestrian.
Remedy: Dealers will replace the rear quarter glass. The recall began on April 30, 2007. Owners may contact daimlerchrysler at 1-800-853-1403.

This recall on nhtsa.gov

October 8, 2004NHTSA 04V481000115 vehicles potentially affected

Service brakes, hydraulic › Antilock/traction control/electronic limited slip

Summary: Certain passenger vehicles equipped with 4-wheel antilock braking system (ABS), 2.4L high output turbocharged engine, and 5-speed manual transaxle, may exhibit inadequate clearance between the left front brake tube and the transaxle housing.
Consequence: Contact between the brake tube and the transaxle housing over an extended period of time may eventually lead to perforation of the brake tube, which could lead to a loss of braking force in the left front/right rear circuit of vehicle.
Remedy: Dealers will install revised brake tubes. The recall began October 25, 2004. Owners should contact daimlerchrysler at 1-800-853-1403.

This recall on nhtsa.gov

June 3, 2004NHTSA 04V268000438,391 vehicles potentially affected

Steering › Hydraulic power assist › Hose, piping, and connections

Summary: On certain passenger vehicles equipped with 2.4L non-turbocharged engines and automatic transaxles, the power steering pressure hose may contact the automatic transaxle differential cover, potentially damaging the hose.
Consequence: Power steering fluid leakage in the presence of an ignition source can result in an underhood fire.
Remedy: Dealers will inspect and relocate, or replace as necessary, the power steering hose and confirm torque of the hose fastener at the steering gear end. The recall began on September 20, 2004. Owners should contact daimlerchrysler at 1-800-853-1403.

This recall on nhtsa.gov

Owner complaints

Owners have filed 187 complaints about the 2005 Chrysler PT Cruiser with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported: 11
Fires reported: 12
Injuries reported: 18
Deaths reported: 0

Most complained-about components

Electrical system25
Steering15
Exterior lighting13
Engine and engine cooling12
Engine11

Other Chrysler PT Cruiser years

Other 2005 Chrysler models

Most recalled 2005 vehicles

2005 Honda Accord (24 recalls)
2005 Ford E-350 (16 recalls)
2005 IC CE (16 recalls)
2005 Thomas Built Buses SAF-T-Liner C2 (16 recalls)
2005 Honda Pilot (15 recalls)

All of 2005’s most recalled vehicles

Questions

Does the 2005 Chrysler PT Cruiser have any recalls?: 5 recalls found in NHTSA data as of September 22, 2026, covering: exterior lighting, suspension, visibility, service brakes, hydraulic, steering. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2005 Chrysler PT Cruiser recall has been fixed?: Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Chrysler dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2005 Chrysler PT Cruiser?: 187 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.