Skip to content
AnyRecalls

2006 Damon Intruder recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

6 recalls found in NHTSA data as of September 22, 2026

For the 2006 Damon Intruder. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Damon been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Damon dealer can also check your VIN. Recall repairs are free.

2006 Damon Intruder recalls, newest first

September 9, 2010NHTSA 10V407000271 vehicles potentially affected

Equipment › Recreational vehicle/trailer › LPG systems › Tank assembly

Summary
Damon is recalling certain model year 2007-2011 challenger, model year 2005-2007 intruder motor homes. These motor homes do not have the proper clearance between the rear suspension leaf spring and the vehicle liquid propane fuel tank. As the suspension travels it is possible for the leaf spring shackle bolt to come in contact with the tank. This potentially could puncture the tank and result in a fire or explosion.
Consequence
In the event of a fire or explosion, there is a potential for property damage, personal injury or death.
Remedy
Damon will inspect to see if the proper clearance between the shackle bolt and the tank exists. If it is found there is not enough clearance, the tank will be relocated to provide the proper clearance. This service will be performed free of charge. The safety recall began on October 6, 2010. Owners may contact damon warranty service department at 877-855-2867.

This recall on nhtsa.gov

June 16, 2009NHTSA 09V2250002,415 vehicles potentially affected

Service brakes, hydraulic

Summary
Damon is recalling 2,415 motorhomes equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag.
Consequence
The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.
Remedy
Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy and owner notification for this campaign please see 09V-110. Owners may contact workhorse at 1-877-246-7731.

This recall on nhtsa.gov

October 9, 2008NHTSA 08V5340004,677 vehicles potentially affected

Equipment › Recreational vehicle/trailer

Summary
Damon is recalling 4,677 my 2004-2006 challenger, daybreak, intruder, my 2004-2005 escaper, ultrasport, and my 2005 astoria and astoria waldorf motor homes equipped with a two-door refrigerator manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
Consequence
Release of coolant under certain conditions could ignite and result in a fire.
Remedy
Damon will be working with dometic in order to repair these refrigerators (please see 08E032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle Inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1-888-446-5157 or damon at

This recall on nhtsa.gov

November 28, 2006NHTSA 06V4510001,517 vehicles potentially affected

Engine and engine cooling

Summary
On certain motor homes built on workhorse chassis and equipped with GM 8.1L V8 engines, improper hardening during the heat treatment process can cause the fuel rail pulse damper retainer clip to fracture, resulting in inadequate retention of the damper. If the damper becomes loose, fuel could be pumped by the fuel pump into the under hood area.
Consequence
In the presence of an ignition source, a fire could result.
Remedy
Chevrolet and workhorse are handling the owner notification and remedy for this campaign (please see 06V225 and 06V289). Dealers will replace the fuel rail pulse damper retainer clips on these engines free of charge. Owners may contact Chevrolet at 1-800-630-2438, workhorse at 877-294-6773, or damon at 1-574-264-5517.

This recall on nhtsa.gov

September 12, 2006NHTSA 06V3470001,592 vehicles potentially affected

Equipment › Recreational vehicle/trailer

Summary
On certain class a motor homes, some hydraulic lines for the leveling jack system may be improperly secured or routed too close to a drive train heat source.
Consequence
This may cause melting of the hydraulic line resulting in leakage of hydraulic fluid, which could cause a fire.
Remedy
Damon will inspect and secure the clearance of the hydraulic leveling hose that may be too close to heat sources. The recall began on September 25, 2006. Owners may contact damon at 1-800-860-3812.

This recall on nhtsa.gov

June 30, 2006NHTSA 06V236000116 vehicles potentially affected

Steering

Summary
Certain motor homes built on workhorse chassis may have been equipped with incorrect steering intermediate shafts. The spline can strip while the steering wheel is being turned.
Consequence
This steering condition could result in a loss of steering control, increasing the risk of a crash.
Remedy
Workhorse is conducting this recall (please see 06V148000) and will inspect and, if necessary, replace the steering intermediate shaft. Owners may contact workhorse at 1-877-294-6773 or damon at 574-264-2900.

This recall on nhtsa.gov

Owner complaints

Owners have filed 2 complaints about the 2006 Damon Intruder with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported
0
Fires reported
0
Injuries reported
0
Deaths reported
0

Most complained-about components

  1. And fittings1
  2. Hydraulic › Foundation components › Hoses1
  3. Lines/piping1
  4. Service brakes1
  5. Structure1

Other Damon Intruder years

Other 2006 Damon models

Most recalled 2006 vehicles

  1. 2006 Ford E-350 (39 recalls)
  2. 2006 Ford E-250 (31 recalls)
  3. 2006 Thomas Built Buses Minotour (22 recalls)
  4. 2006 Freightliner Columbia (21 recalls)
  5. 2006 Thomas Built Buses SAF-T-Liner C2 (21 recalls)
All of 2006’s most recalled vehicles

Questions

Does the 2006 Damon Intruder have any recalls?
6 recalls found in NHTSA data as of September 22, 2026, covering: equipment, service brakes, hydraulic, engine and engine cooling, steering. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2006 Damon Intruder recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Damon dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2006 Damon Intruder?
2 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.