2003 Ford E-550 recalls

Vehicle speed control

Summary

Ford is recalling model years 1995-2003 windstar, 2000-2003 excursion diesel, 1993-1997 and 1999-2003 F-250 sd through F-550 sd diesel, 1992-2003 E-150 through E-550, 1995-2002 explorer, 1997 and 2002 Mercury mountaineer, 1995-1997 and 2001-2003 ranger, and 1994 F53 vehicles equipped with the texas instruments speed control deactivation switch (scds). The scds may leak internally and then overheat, smoke, or burn.

Consequence

A vehicle fire could occur with or without the engine running.

Remedy

Ford will notify owners that dealers will install a fused wiring harness in line with the scds. On 1999-2003 windstar vehicles with a leaking scds, dealers will also inspect the ABS control module connector and repair as necessary. Repairs will be completed free of charge. The safety recall began on October 27, 2009. Owners may contact Ford at 1-888-222-2751.

This recall on nhtsa.gov

Vehicle speed control

Summary

On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat.

Consequence

Overheating could result in smoke, burn, or an underhood fire.

Remedy

Dealers will install a fused wiring harness into the speed control system free of charge. The recall began on March 12, 2007. Owners may contact Ford at 1-800-392-3673. (note: also see recalls 05V017, 05V388, and 06V286)

This recall on nhtsa.gov

Fuel system, gasoline

• Aftermarket equipment: applies only if this part was installed

Summary

Certain aftermarket fuel filters sold under the purolator brand name, p/n F65277, shipped from January 16 through June 2, 2006, for use on the above listed passenger vehicles. Due to incorrect design, the quick connectors may not fully seat with the tube interface, even though the person making the connection may believe that the quick connector is fully attached.

Consequence

Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur.

Remedy

Ufi will notify owners and replace the filters free of charge. The recall began on August 4, 2006. Owners may contact ufi filters USA at 800-230-5876.

This recall on nhtsa.gov

Engine and engine cooling

Summary

On certain vans, the air filter element material process resulted in an air filter paper element that can smolder or burn. This change in filter paper composition combined with the configuration of the air induction system, may allow hot carbon particles to contact the air filter element during certain driving conditions that create hot particles.

Consequence

These hot particles may ignite the air filter element with the potential for air induction system damage or underhood fire.

Remedy

Dealers will inspect and replace the air filter element. The recall began September 27, 2004. Owners should contact Ford at 1-800-392-3673. Also Ford is extending the limited warranty (for a one time replacement) of the ABS module for a total of 10 years or 150,000 miles from the warranty start date, whichever occurs first. If your vehicle has already accumulated more than 150,000 miles, this coverage will last until September 30, 2005.

This recall on nhtsa.gov

Electrical system › Wiring

Summary

On certain vans, a diode in the anti-lock braking system (ABS) module may experience an electrical short.

Consequence

The electrical short may cause an ABS malfunction that would illuminate the ABS warning light, or the module may overheat resulting in a burning odor, smoke, and/or fire. This condition may occur while the vehicle is being driven or unattended.

Remedy

Dealers will install a new fuse in the ABS circuit and install a heat shield over the ABS module. The recall began on October 15, 2004. Owners should contact Ford at 1-800-392-3673. Also Ford is extending the limited warranty (for a one time replacement) of the ABS module for a total of 10 years or 150,000 miles from the warranty start date, whichever occurs first. If your vehicle has already accumulated more than 150,000 miles, this coverage will last until September 30, 2005.

This recall on nhtsa.gov