Skip to content
AnyRecalls

1991 Ford Escort recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

4 recalls found in NHTSA data as of September 22, 2026

For the 1991 Ford Escort. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Ford been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. Recall repairs are free.

1991 Ford Escort recalls, newest first

June 2, 1994NHTSA 94E019000919 vehicles potentially affected

Suspension › Front

  • Aftermarket equipment: applies only if this part was installed
Summary
The offset toe adjusting pin can fracture under conditions such as torsional loads, flexing motion, impact loads, and overtorquing.
Consequence
This can result in loss of vehicle steering control andan accident.
Remedy
Dana will pay for replacement and labor costs of the adjustment pin without charge to the installing facility and the vehicle owner. These pins should be replaced by a Ford original equipment pin assembly. Owner or installer inquiries concerning this recall campaign should contact dana service center at 1-800-248-9606.

This recall on nhtsa.gov

April 15, 1993NHTSA 93V05700091,000 vehicles potentially affected

Electrical system › Ignition › Anti-theft › Control module

Summary
The roll pins securing the ignition lock in the steering column housing can separate or move out of position.
Consequence
The ignition lock cylinder may disengage from thesteering column housing which could cause the steering column to lock up,resulting in loss of vehicle control and a possible accident.
Remedy
If one or both of the roll pins are missing or not fully inserted, the ignition lock housing will be replaced, along with the door-locks and the liftgate or deck-lid locks so that key compatibility is maintained. If both pins are present and fully inserted, a plastic snap-on sleeve will be installed as a precaution to prevent the roll pins from coming out.

This recall on nhtsa.gov

August 19, 1992NHTSA 92V11700022,000 vehicles potentially affected

Fuel system, gasoline

Summary
Fatigue cracks can develop in the solder joint between the fuel return tube and the fuel pump sending unit located at the top of the fuel tank.
Consequence
Should a crack develop, fuel vapor can escape from thetank when the tank is full, and a small amount of fuel can leak from the crack.fuel leaks can result in fire when exposed to a source of ignition.
Remedy
Install a new fuel pump sending assembly.

This recall on nhtsa.gov

April 17, 1990NHTSA 90V0760006,000 vehicles potentially affected

Vehicle speed control › Accelerator pedal

Summary
Interference occur between bolt that secures a fuel line shield to the lower portion of the dash panel and the accelerator pedal.
Consequence
This could cause the accelerator pedal to stick at the wide open throttle position and result in loss of control with the risk of a vehicle accident.
Remedy
Cut off extra length of bolt that protrudes above surface of weld nut to prevent interference.

This recall on nhtsa.gov

Owner complaints

Owners have filed 327 complaints about the 1991 Ford Escort with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported
20
Fires reported
61
Injuries reported
16
Deaths reported
2

Most complained-about components

  1. Fuel system70
  2. Electrical system › Ignition › Switch49
  3. Seat belts46
  4. Gasoline › Delivery › Fuel pump24
  5. Gasoline › Storage › Tank assembly21

Other Ford Escort years

Other 1991 Ford models

Most recalled 1991 vehicles

  1. 1991 Honda Accord (13 recalls)
  2. 1991 Blue Bird TC2000 (12 recalls)
  3. 1991 Acura Integra (11 recalls)
  4. 1991 Thomas School Bus (11 recalls)
  5. 1991 Chevrolet Caprice (10 recalls)
All of 1991’s most recalled vehicles

Questions

Does the 1991 Ford Escort have any recalls?
4 recalls found in NHTSA data as of September 22, 2026, covering: suspension, electrical system, fuel system, gasoline, vehicle speed control. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 1991 Ford Escort recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Ford dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 1991 Ford Escort?
327 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.