Skip to content
AnyRecalls

2005 International 9200I recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

4 recalls found in NHTSA data as of September 22, 2026

For the 2005 International 9200I. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your International been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A International dealer can also check your VIN. Recall repairs are free.

2005 International 9200I recalls, newest first

May 18, 2023NHTSA 23V35300032,880 vehicles potentially affected

Exterior lighting › Back up lights

Summary
Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence
Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.
Remedy
Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514.

This recall on nhtsa.gov

October 5, 2009NHTSA 09V3860009,527 vehicles potentially affected

Engine and engine cooling

Summary
Navistar is recalling certain model year 2003 through 2008 heavy trucks manufactured between April 1, 2003 and December 21, 2007, equipped with caterpillar C15 engines. The variable valve actuation (vva) oil line may wear against the p-clips retaining the oil line, causing an oil leak.
Consequence
An oil leak could result in a fire.
Remedy
Navistar is working with caterpillar to repair the engines free of charge. Please see 09E-020. The safety recall began on October 23, 2009. Owners may contact caterpillar at 1-800-447-4986 or navistar at 1-260-461-1890.

This recall on nhtsa.gov

October 4, 2005NHTSA 05V448000125 vehicles potentially affected

Seat belts › Front › Webbing

Summary
On certain heavy duty truck/tractors equipped with sears atlas series 35, 70, or 80 driver's seats, when the seats are in their lowest, most rearward adjusted position, they may chafe the seat belt tether that connects from the seat to the back of the cab.
Consequence
This chafing may eventually cut through the tether, thus weakening the effectiveness of the seat belt assembly in a vehicle crash, possibly resulting in property damage, personal injury or death.
Remedy
Dealers will inspect the vehicles for suspect seat codes and will replace the existing 12" seat tethers with new 13.5" tethers. The recall began on October 7, 2005. Owners may contact international at 1-800-448-7825.

This recall on nhtsa.gov

June 24, 2005NHTSA 05V29600049,607 vehicles potentially affected

Electrical system › 12V/24V/48V battery › Cables

Summary
On certain 4X2 and 6X4 heavy duty trucks, the positive battery cable between the batteries and the starter may rub against an electrical ground cable between the starter and frame rail.
Consequence
This chafing could cause an electrical short and/or fire.
Remedy
Dealers will inspect the vehicles to determine if any chafing has occurred between positive and negative cables. If there is no evidence of chafing, then a saddle clamp will be installed to ensure cables will not rub. If there is evidence of chafing, the damaged cables will be replaced and the swivel saddle clamp installed. The recall began on August 22, 2005. Owners may contact international at 1-800-448-7825.

This recall on nhtsa.gov

Owner complaints

No owner complaints about the 2005 International 9200I were found in NHTSA’s complaint data.

Other International 9200I years

Other 2005 International models

Most recalled 2005 vehicles

  1. 2005 Honda Accord (24 recalls)
  2. 2005 Ford E-350 (16 recalls)
  3. 2005 IC CE (16 recalls)
  4. 2005 Thomas Built Buses SAF-T-Liner C2 (16 recalls)
  5. 2005 Honda Pilot (15 recalls)
All of 2005’s most recalled vehicles

Questions

Does the 2005 International 9200I have any recalls?
4 recalls found in NHTSA data as of September 22, 2026, covering: exterior lighting, engine and engine cooling, seat belts, electrical system. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2005 International 9200I recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a International dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2005 International 9200I?
0 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.