Skip to content
AnyRecalls

2004 Itasca Sundancer recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

4 recalls found in NHTSA data as of September 22, 2026

For the 2004 Itasca Sundancer. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Itasca been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Itasca dealer can also check your VIN. Recall repairs are free.

2004 Itasca Sundancer recalls, newest first

November 28, 2006NHTSA 06V4560001,491 vehicles potentially affected

Equipment › Electrical › Radio/tape deck/cd etc.

Summary
On certain motor homes equipped with front overhead televisions, incorrect fasteners were used to secure the television located in the front overhead area of the motor home.
Consequence
The television may become loose and possibly fall from its position which has the potential to impact the driver or passengers, resulting in personal injury and/or vehicle and property damage.
Remedy
Dealers will inspect the vehicle to assure the correct fasteners (bolts) were used in the tv retention strap. The recall began on December 15, 2006. Owners may contact winnebago at 1-800-537-1885.

This recall on nhtsa.gov

October 20, 2004NHTSA 04V5160005,125 vehicles potentially affected

Engine and engine cooling

Summary
On motor homes built on Ford e-series chassis, the air filter element material process resulted in an air filter paper element that can smolder or burn. This change in filter paper composition combined with the configuration of the air induction system, may allow hot carbon particles to contact the air filter element during certain driving conditions that create hot particles.
Consequence
These hot particles may ignite the air filter element with the potential for air induction system damage or underhood fire.
Remedy
Ford motor company is conducting the owner notification and remedy for this campaign. Dealers will inspect and replace the air filter element. Owners should contact Ford at 1-800-392-3673 or winnebago at 641-585-3535.

This recall on nhtsa.gov

October 20, 2004NHTSA 04V5120003,950 vehicles potentially affected

Electrical system › Wiring

Summary
On motor homes built on Ford e-series chassis and equipped with gas engines, a diode in the anti-lock braking system (ABS) module may experience an electrical short.
Consequence
The electrical short may cause an ABS malfunction that would illuminate the ABS warning light, or the module may overheat resulting in a burning odor, smoke, and/or fire. This condition may occur while the vehicle is being driven or unattended.
Remedy
Ford motor company is conducting the owner notification and remedy for this campaign. Dealers will install a new fuse in the ABS circuit and install a heat shield over the ABS module. Owners should contact Ford at 1-800-392-3673 or winnebago at 641-585-3535.

This recall on nhtsa.gov

October 16, 2003NHTSA 03V40500015,337 vehicles potentially affected

Equipment › Recreational vehicle/trailer

Summary
On certain motor homes equipped with samsung microwave ovens, these units were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This may cause the oven to activate without pressing any key pads.
Consequence
An electrical short can occur causing the oven to activate without pressing any key pads. This could result in excessive heat, smoke, or possibly a fire.
Remedy
Samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or winnebago at 641-585-3535.

This recall on nhtsa.gov

Owner complaints

No owner complaints about the 2004 Itasca Sundancer were found in NHTSA’s complaint data.

Other Itasca Sundancer years

Other 2004 Itasca models

Most recalled 2004 vehicles

  1. 2004 Honda Accord (22 recalls)
  2. 2004 Ford E-250 (18 recalls)
  3. 2004 Blue Bird Vision (17 recalls)
  4. 2004 Ford F-150 (16 recalls)
  5. 2004 Chevrolet Silverado (15 recalls)
All of 2004’s most recalled vehicles

Questions

Does the 2004 Itasca Sundancer have any recalls?
4 recalls found in NHTSA data as of September 22, 2026, covering: equipment, engine and engine cooling, electrical system. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2004 Itasca Sundancer recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Itasca dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2004 Itasca Sundancer?
0 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.