Skip to content
AnyRecalls

1999 New Flyer D35LF recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

6 recalls found in NHTSA data as of September 22, 2026

For the 1999 New Flyer D35LF. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your New Flyer been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A New Flyer dealer can also check your VIN. Recall repairs are free.

1999 New Flyer D35LF recalls, newest first

February 23, 2007NHTSA 07V0680001,707 vehicles potentially affected

Exterior lighting

Summary
Certain transit buses fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps reflective devices, and associated equipment." the flashing deceleration lamps were an optional item for some of these buses.
Consequence
The standard requires that the deceleration lamp is a solid light rather than a flashing light.
Remedy
Dealers will rewire the electrical system to remove the flashing function or install a new programmable logic controller (plc) which will make the lamps burn steady free of charge. The recall began on March 5, 2007. Owners may contact new flyer at 204-934-4874.

This recall on nhtsa.gov

May 22, 2002NHTSA 02V112000480 vehicles potentially affected

Steering › Hydraulic power assist › Hose, piping, and connections

Summary
On certain low floor buses, the power steering hose was incorrectly installed.
Consequence
The hose can leak, creating the risk of an engine fire.
Remedy
Dealers will replace the hose. Owner notification began July 1, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact new flyer at 1-204-228-8984.

This recall on nhtsa.gov

February 14, 2002NHTSA 02V0590011,771 vehicles potentially affected

Structure › Body › Door

Summary
On certain low floor transit buses equipped with adhesively bonded aluminum bus door panels, due to an imperfect bonding of the door panel skin to the panel frame, environmental moisture may infiltrate regions of imperfect bonding and cause separation of the frame and door panel.
Consequence
Under these conditions, if the panel is separating or has separated, a passenger could fall from the bus onto the roadway, possibly resulting in personal injury or death.
Remedy
Vapor will notify customers to have their buses inspected and will install mechanical fasteners to attach the skins to the frame elements free of charge. Owner notification began December 10, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact vapor corporation at 847-967-8300 or new flyer at 1-204-224-1251.

This recall on nhtsa.gov

August 22, 2001NHTSA 01V2650001,552 vehicles potentially affected

Steering › Linkages › Tie rod assembly

Summary
Vehicle description: transit buses. The clamp nuts for the center link tie rods may have been inadequately tightened.
Consequence
Inadequately tightened clamp nuts could lead to the tie rods separating from the center link possibly resulting in a vehicle crash.
Remedy
New flyer will will inspect the tie rod end clamp lock nuts to ensure that the nuts are properly tightened. Any damaged tie rods will be replaced. Owner notification began September 17, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact new flyer at 1-204-982-8181.

This recall on nhtsa.gov

April 30, 2001NHTSA 01V0330062,100 vehicles potentially affected

Electrical system › 12V/24V/48V battery

Summary
Vehicle description: transit buses equipped with vanner 60 series battery equalizers. The equalizer could fail to operate properly and cause malfunction of the battery charging system.
Consequence
Without fusing, the equalizer may melt, burn, or smoke, possibly resulting in a fire or a smoke filled bus, thus necessitating a passenger evacuation of the bus. The failure mode can cause operator distraction, and/or possible personal injury.
Remedy
Dealers will inspect the buses for certain equalizers by the date code. The affected equalizers will be replaced by vanner. New flyer is conducting the owner notification for this campaign. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact vanner at 1-800-227-6937 or new flyer at 1-204-982-8413.

This recall on nhtsa.gov

September 15, 2000NHTSA 00V275000206 vehicles potentially affected

Service brakes, air

Summary
Vehicle description: certain transit buses equipped with ABS fail to comply with the requirements of FMVSS no. 121, "air brake systems." the rear brake release time can exceed the requirements.
Consequence
A slow brake release can cause premature brake wear, increasing the risk of a crash.
Remedy
The repair will involve installing a quick release valve or increasing the size of the rear brake control line.

This recall on nhtsa.gov

Owner complaints

No owner complaints about the 1999 New Flyer D35LF were found in NHTSA’s complaint data.

Other New Flyer D35LF years

Other 1999 New Flyer models

Most recalled 1999 vehicles

  1. 1999 Ford F-250 (19 recalls)
  2. 1999 Ford F-150 (18 recalls)
  3. 1999 Honda Accord (17 recalls)
  4. 1999 Chevrolet Silverado (16 recalls)
  5. 1999 Blue Bird All American (16 recalls)
All of 1999’s most recalled vehicles

Questions

Does the 1999 New Flyer D35LF have any recalls?
6 recalls found in NHTSA data as of September 22, 2026, covering: exterior lighting, steering, structure, electrical system, service brakes, air. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 1999 New Flyer D35LF recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a New Flyer dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 1999 New Flyer D35LF?
0 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.