Skip to content
AnyRecalls

2002 Volvo VN recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

5 recalls found in NHTSA data as of September 22, 2026

For the 2002 Volvo VN. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Volvo been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Volvo dealer can also check your VIN. Recall repairs are free.

2002 Volvo VN recalls, newest first

October 18, 2012NHTSA 12V5100001,496 vehicles potentially affected

Seat belts

Summary
Volvo is recalling certain model year 2002-2013 VHD and VN trucks, manufactured from August 4, 2000, through June 22, 2012, and equipped with bench passenger seats. The seat belt d-ring weld may not be sufficient enough to meet the seat belt pull test. Therefore, these vehicles fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 210, "Seat Belt Assembly Anchorages."
Consequence
In the event of a crash, an insufficient seat belt weld may prevent the seat belt from properly restraining the occupant. This increases the risk of injury to the seat occupant.
Remedy
Volvo Trucks of America will notify owners, and dealers will replace the suspected d-ring, free of change. The safety recall began on May 10, 2013. Owners may contact Volvo at 1-336-393-2000.

This recall on nhtsa.gov

September 17, 2004NHTSA 04V45700056,154 vehicles potentially affected

Visibility › Windshield wiper/washer › Motor

Summary
On certain trucks equipped with valeo wiper systems, the wiper motor may be susceptive to salt intrusion that could possibly lead to a condition where the connector overheats to a point where the connector could ignite.
Consequence
If this occurs, excessive heat and smoke could result in an under hood fire.
Remedy
Dealers will inspect and replace the connector plate on the windshield wiper motor. Phase 2 of the recall began on November 1, 2004. Owners should contact Volvo trucks at 1-800-528-6586.

This recall on nhtsa.gov

July 2, 2004NHTSA 04V3150001,374 vehicles potentially affected

Trailer hitches › Fifth wheel assembly

Summary
On certain trucks, a malfunction in the solenoid valve may allow air to be released to fifth wheel latch when the park brake is engaged.
Consequence
This condition could cause the fifth wheel latch to release inadvertently when the park brake is engaged, creating the potential for loss of the trailer. A crash could occur without prior warning.
Remedy
Dealers will add an additional solenoid valve in series with the existing pneumatic circuit for the fifth wheel air release. The recall began on August 9, 2004. Owners should contact Volvo at 1-800-528-6586.

This recall on nhtsa.gov

February 13, 2004NHTSA 04V0770002,112 vehicles potentially affected

Engine and engine cooling

Summary
On certain heavy-duty class 8 trucks, the assembled engine pre-heater jumper wiring harness was incorrectly assembled.
Consequence
The engine pre-heater could overheat resulting in damage to the pre-heater and other engine heat sensitive components near the pre-heater and the ability to re-start the engine could be compromised, increasing the risk of a crash.
Remedy
Dealers will repair the affected circuits in the jumper wiring harness connector. Owner notification is expected to begin during March 2004. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Volvo trucks at 1-800-528-6586.

This recall on nhtsa.gov

November 25, 2002NHTSA 02V317000213 vehicles potentially affected

Suspension › Multiple axle

Summary
On certain heavy duty class 8 trucks with Volvo b-ride rear suspension, the forward and/or rear drive axle upper axle seat could break allowing the affected axle to shift out of alignment.
Consequence
This condition could result in loss of axle stability, increasing the risk of a crash.
Remedy
Dealers will replace the upper axle seat on both rear drive axles. Owner notification began January 14, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Volvo trucks at 1-800-528-6586.

This recall on nhtsa.gov

Owner complaints

No owner complaints about the 2002 Volvo VN were found in NHTSA’s complaint data.

Other Volvo VN years

Other 2002 Volvo models

Most recalled 2002 vehicles

  1. 2002 Honda Civic (24 recalls)
  2. 2002 Jeep Grand Cherokee (16 recalls)
  3. 2002 Honda Accord (16 recalls)
  4. 2002 Honda CR-V (16 recalls)
  5. 2002 Chevrolet Silverado (15 recalls)
All of 2002’s most recalled vehicles

Questions

Does the 2002 Volvo VN have any recalls?
5 recalls found in NHTSA data as of September 22, 2026, covering: seat belts, visibility, trailer hitches, engine and engine cooling, suspension. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2002 Volvo VN recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Volvo dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2002 Volvo VN?
0 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.