Skip to content
AnyRecalls

2004 Chevrolet Corvette recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

4 recalls found in NHTSA data as of September 22, 2026

For the 2004 Chevrolet Corvette. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Chevrolet been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Chevrolet dealer can also check your VIN. Recall repairs are free.

2004 Chevrolet Corvette recalls, newest first

May 11, 2009NHTSA 09E02500042,540 vehicles potentially affected

Exterior lighting › Headlights

  • Aftermarket equipment: applies only if this part was installed
Summary
Dope, Inc. Is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence
Decreased lighting visibility may result in a vehicle crash.
Remedy
Dope, Inc. Will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on July 28, 2009. Owners may contact dope, Inc. At 1-626-272-1798.

This recall on nhtsa.gov

April 7, 2009NHTSA 09E01200016,270 vehicles potentially affected

Exterior lighting

  • Aftermarket equipment: applies only if this part was installed
Summary
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence
Decreased lighting visibility may result in a vehicle crash.
Remedy
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.

This recall on nhtsa.gov

June 9, 2004NHTSA 04V27300041,928 vehicles potentially affected

Steering › Linkages

Summary
On certain passenger vehicles involved in this campaign, the lower control arm ball stud nut/washer assemblies with washers were made of the wrong material. The washers may fracture and become loose or fall away from the vehicle, reducing clamp load. Separation of the control arm ball stud and steering knuckle, due to disengagement of the tapered attachment and retaining nut, is possible.
Consequence
If the control arm separates from the knuckle, the affected corner of the vehicle will drop and the control arm would be forced downward, contacting the wheel. The affected wheel could tilt outward and create a dragging action that would tend to slow the vehicle and create a tendency for the vehicle to turn in the direction of the affected wheel. In extreme situations, the affected wheel assembly could separate from the vehicle. Separation of the wheel assembly would also sever that wheel;s hydraulic brake hose and result in diminished braking performance of the vehicle, which could result in a crash.
Remedy
Dealers will inspect the ball stud joints and measure the torque of the nut for all front lower control arms in all models affected as well as the rear lower control arms on the xlr and corvette. If the torque is not at specification, the dealers will replace the ball stud, the knuckle, and the nut. If the torque is at specification, the dealers will replace the nut/washer assembly only. The recall will begin on August 25, 2004. Owners should contact Cadillac at 1-866-982-2339 or Chevrolet at 1-800-630-2438.

This recall on nhtsa.gov

February 9, 2004NHTSA 04V060000126,624 vehicles potentially affected

Steering › Column locking › Anti-theft device

Summary
On certain passenger vehicles equipped with electronic column lock systems (ecl), when the ignition switch is turned to "lock," the ecl system prevents turning of the steering system. When the vehicle is started, the ecl unlocks the steering system. The vehicle is designed so that if the column fails to unlock when the vehicle is started and the customer tries to drive, the fuel supply will be shut off so that the vehicle cannot move when the vehicle cannot be steered. If voltage at the powertrain control module is low or interrupted, however, the fuel shut off may not occur and the vehicle can be accelerated while the steering system is locked. Also when the control system shows that the ecl is unlocked and the vehicle is being driven, the lock pin location can vary. Depending on the location of the lock plate relative to the switch transition point, there could then be contact between the lock plate and pin causing the steering to lock while driving.
Consequence
If this occurs, a crash could occur without warning.
Remedy
On vehicles equipped with an automatic transmission, the dealer will disable the steering column lock by removing the column lock plate. When the ignition key is removed, the transmission shifter will lock but the steering column will not lock. On vehicles equipped with a manual transmission, the dealer will reprogram the powertrain control module, perform a dimensional check of the column lock and, if necessary, replace the lock plate. The steering column on these vehicles will continue to lock when the key is removed. Owner notification to owners of 1997 vehicles equipped with automatic transmissions began on April 26, 2004. Owners of 1998 through 2004 vehicles (except 1997-1998 manual transmission vehicles) will be notified beginning on August 2, 2004. The remaining owners (1997-1998 manual transmission vehicles) will be notified later in 2004, when parts are available. Owners should contact Chevrolet at 1-800-630-2438.

This recall on nhtsa.gov

Owner complaints

Owners have filed 217 complaints about the 2004 Chevrolet Corvette with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported
4
Fires reported
1
Injuries reported
2
Deaths reported
0

Most complained-about components

  1. Fuel system99
  2. Gasoline78
  3. Fuel/propulsion system52
  4. Steering26
  5. Gasoline › Storage › Tank assembly12

Other Chevrolet Corvette years

Other 2004 Chevrolet models

Most recalled 2004 vehicles

  1. 2004 Honda Accord (22 recalls)
  2. 2004 Ford E-250 (18 recalls)
  3. 2004 Blue Bird Vision (17 recalls)
  4. 2004 Ford F-150 (16 recalls)
  5. 2004 Chevrolet Silverado (15 recalls)
All of 2004’s most recalled vehicles

Questions

Does the 2004 Chevrolet Corvette have any recalls?
4 recalls found in NHTSA data as of September 22, 2026, covering: exterior lighting, steering. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2004 Chevrolet Corvette recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Chevrolet dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2004 Chevrolet Corvette?
217 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.