Skip to content
AnyRecalls

2005 Chevrolet Corvette recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

6 recalls found in NHTSA data as of September 22, 2026

For the 2005 Chevrolet Corvette. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Chevrolet been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Chevrolet dealer can also check your VIN. Recall repairs are free.

2005 Chevrolet Corvette recalls, newest first

May 14, 2014NHTSA 14V251000103,158 vehicles potentially affected

Exterior lighting › Headlights

Summary
General Motors LLC (GM) is recalling certain model year 2005-2007 Chevrolet Corvette vehicles manufactured March 29, 2004, through June 22, 2007. In the affected vehicles, the underhood bussed electrical center (UBEC) housing can expand and cause the headlamp low beam relay control circuit wire to bend. If the wire is repeatedly bent, it may fracture causing a loss of low beam headlamp illumination.
Consequence
The loss of low beam headlamp illumination will decrease the driver's visibility, as well as the vehicle's conspicuity to other motorists, increasing the risk of a crash.
Remedy
GM will notify owners, and dealers will install a jumper wire to correct this condition, free of charge. The recall began January 2, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 13146. Note: Model year 2008-2013 Chevrolet Corvettes will be covered under customer satisfaction program number 14203 for the same issue.
Components
Exterior lighting › Headlights; Electrical system › Wiring

This recall on nhtsa.gov

April 26, 2010NHTSA 10V17200040,028 vehicles potentially affected

Steering › Column

Summary
GM is recalling certain model year 2005 and 2006 Chevrolet corvette passenger cars manufactured between March 2004 and January 2006 equipped with a tilt and telescoping steering column (rpo N37). In rare cases, repeated movement of the steering column may cause a signal interruption within the column. If this occurs, the message, "service active handling system" will appear in the driver information center, and one or more of the brakes may apply, possibly causing the vehicle to pull to the right or left.
Consequence
If the driver does not respond to the change in vehicle movement, a crash could occur.
Remedy
GM will notify owners and dealers will repair the vehicles free of charge. The safety recall began on April 30, 2010. Owners may contact Chevrolet at 1-800-630-2438 and GMC at 1-866-996-9463 or at the owner center at www.gmownercenter.com.

This recall on nhtsa.gov

December 23, 2009NHTSA 09V49100022,090 vehicles potentially affected

Structure › Body › Roof and pillars

Summary
General motors is recalling certain model year 2005 through 2007 corvette vehicles equipped with a removable roof and model year 2006 and 2007 corvette Z06 vehicles. The adhesive between the roof panel and the frame may separate. If there is a partial separation, the driver may notice one or more symptoms, such as a snapping noise when driving over bumps, wind noise, poor roof panel fit, roof panel movement/bounce when a door or hatch is closed, or a water leak in the headliner.
Consequence
If there is a complete separation, the roof panel may detach from the vehicle. If this were to occur while the vehicle was being driven, it could strike a following vehicle and cause injury and/or property damage.
Remedy
Dealers will install a new design roof panel free of charge. The safety recall is expected to begin during April 2010. Owners may contact Chevrolet at 1-800-630-2438 or at www.gmownercenter.com.

This recall on nhtsa.gov

May 24, 2006NHTSA 06V18100030,793 vehicles potentially affected

Structure › Body › Roof and pillars

Summary
On certain 2005-2006 Chevrolet corvettes equipped with painted roofs, the adhesive between the roof panel and the frame may separate.
Consequence
If there is a complete separation, the roof panel may detach from the vehicle and it could strike another vehicle and cause injury and property damage.
Remedy
Dealers will inspect vehicles free of charge for potential roof panel-to- frame separation and add the specified adhesive foam or replace the roof with one having adhesive foam. The recall began on October 19, 2006. Owners may contact Chevrolet at 1-800-630-2438.

This recall on nhtsa.gov

October 5, 2005NHTSA 05V455000123,592 vehicles potentially affected

Steering › Hydraulic power assist › Hose, piping, and connections

Summary
Certain passenger vehicles may have been built with a power steering hose that is not to specification. Under extreme steering maneuvers, such as turning the steering wheel fully to the left or right while braking, the hose may fracture and leak fluid.
Consequence
If this were to occur, power steering assist would be lost and increased steering effort would be required. On vehicles equipped with hydro-boost power brakes, it could also result in loss of power brake assist and increased braking effort would be required. If the power steering fluid spray were to spray onto hot engine parts, an engine compartment fire could occur.
Remedy
Dealers will inspect the power steering hose(s) for two suspect date codes and replace them if required. The recall will begin on October 14, 2005. Owners may contact Chevrolet at 1-800-630-2438, GMC at 1-866-996-9463, Buick at 1-866-608-8080, Cadillac at 1-866-982-2339, Isuzu at 1-800-255-6727, or hummer at 1-800-732-5493.

This recall on nhtsa.gov

November 3, 2004NHTSA 04V5250005,225 vehicles potentially affected

Service brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittings

Summary
Certain passenger vehicles were produced with one or both rear brake hydraulic lines that can come in contact with or be affected by heat from the left engine exhaust manifold and the left exhaust pipe. The brake fluid could reach elevated temperatures and boil.
Consequence
If the brake fluid boils in a rear brake line, the effectiveness of the rear brake system would be reduced which could result in a brake line leak and loss of brake fluid. If enough fluid leaks from the rear brake system so that brake pedal application can no longer build pressure to the rear brakes. The operator of the vehicle will experience limited braking which could result in a crash.
Remedy
Dealers will (1) inspect the left engine exhaust manifold clip for proper alignment and placement on the body-mounted stud. If incorrect, they will reposition the clip on the brake lines and reinstall the clip on the stud; (2) the dealer will verify that both rear brake lines have the proper clearance to the left exhaust pipe. They will reposition the lines by bending as necessary; (3) dealers will remove the machining tab from the rear differential housing. Also, dealers are to inspect the brake lines for wear in these related areas and repair or replace if there is any sign of wear-through on the nylon overcoating. The recall began on January 18, 2005. Owners should contact Cadillac at 1-866-982-2239 or Chevrolet at 1-800-630-2438.

This recall on nhtsa.gov

Owner complaints

Owners have filed 532 complaints about the 2005 Chevrolet Corvette with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported
11
Fires reported
6
Injuries reported
6
Deaths reported
0

Most complained-about components

  1. Electrical system95
  2. Electronic stability control (ESC)90
  3. Exterior lighting83
  4. Steering69
  5. Power train66

Other Chevrolet Corvette years

Other 2005 Chevrolet models

Most recalled 2005 vehicles

  1. 2005 Honda Accord (24 recalls)
  2. 2005 Ford E-350 (16 recalls)
  3. 2005 IC CE (16 recalls)
  4. 2005 Thomas Built Buses SAF-T-Liner C2 (16 recalls)
  5. 2005 Honda Pilot (15 recalls)
All of 2005’s most recalled vehicles

Questions

Does the 2005 Chevrolet Corvette have any recalls?
6 recalls found in NHTSA data as of September 22, 2026, covering: exterior lighting, electrical system, steering, structure, service brakes, hydraulic. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2005 Chevrolet Corvette recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Chevrolet dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2005 Chevrolet Corvette?
532 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.