1996 Chevrolet G30 recalls

Equipment

• Aftermarket equipment: applies only if this part was installed

Summary

Certain honeywell fram racing brand HP4 and HP8 oil filters that were manufactured from may 25, 2006, through September 14, 2007, and sold for use as replacement equipment for vehicles list above. The affected filters are marked with a date code A61451 through A72571 sequentially. The date code and part number appear on the filter housing. Fram racing HP4 and HP8 oil filters not bearing a date code in this range are not affected by this recall. The gasket of the oil filter becomes more pliable under high temperatures and pressures.

Consequence

This condition may cause inadequate sealing and loss of engine oil, possibly resulting in a fire.

Remedy

Honeywell will replace the affected oil filters free of charge. The recall began during November 2007. Owners can contact fram customer service toll-free at 1-800-890-2075.

This recall on nhtsa.gov

Fuel system, gasoline

• Aftermarket equipment: applies only if this part was installed

Summary

Certain replacement fuel filters, fram brand name p/n G3727, with date codes X52911 through X60801 sequentially or X600141 and a mexico country or origin marking on the fuel filter housing manufactured from October 18, 2005, through March 21, 2006, sold for use on the vehicles listed above and on certain school buses. (to see the school bus engine sizes, click on "document search" and then "bus applications"). The connector on the fuel filter was not manufactured to honeywell's specification. As a result, the o-ring may not seat correctly on the fuel line.

Consequence

This condition may cause an inadequate seal at the connection, potentially leading to a fuel leak. In the presence of an ignition source, a fire could occur.

Remedy

Honeywell will notify owners and replace the fuel filters free of charge. The recall began on October 18, 2006. Owners may contact fram customer service at 1-800-890-2075 (option 1).

This recall on nhtsa.gov

Steering › Linkages

Summary

The steering linkage assemby contains a relay rod tapered-stud attachment nut that was not torqued to proper specifications.

Consequence

The tapered stud can loosen and the driver would notice a lag in the responsiveness to steering wheel inputs. Eventually the relay rod stud can fracture resulting loss of steering control.

Remedy

Dealers will remove the existing crimped nut and install a new nut torqued to specifications.

This recall on nhtsa.gov

Electrical system › Wiring › Fuses and circuit breakers

Summary

Water intrusion into the kick panel areas in front of both the driver and passenger doors can cause a corrosion path between the battery feed and the electrical ground.

Consequence

This condition can cause an electrical short leading to ignition and combusion of the plastics in the electrical components of the vehicle resulting in a vehicle fire.

Remedy

Dealers will replace the 25 amp circuit breakers with 25 amp fuses in the fuse block; remove a temporary paper fuse-block cover; install a plastic shield over the fuse block; replace and reorient the power door lock relay (if equipped); inspect the remote keyless entry module (if equipped) for signs of corrosion, replace if corroded, and reorient it; and apply additional body sealer in key areas.

This recall on nhtsa.gov

Tires › Bead

Summary

These tires have bead damage which occured during tire mounting.

Consequence

This damage to the tire reinforcing structure in the bead "toe" area causes a bulge in the sidewall after the tire is inflated. This condition will result in a slow air loss causing the tire to go flat. However, it is possible for the damage to result in a rapid air loss causing injuries to anyone if they were handling the tire when this occurred.

Remedy

Dealers will demount each tire and inspect for bead damage. If bead damage is found, the tire will be replaced.

This recall on nhtsa.gov

Suspension › Rear › Springs › Leaf spring assembly › U-bolt, leaf spring to axle

Summary

One of the four rear axle u-bolts can break. This can potentially lead to the spring lifting from the axle under certain rebound, braking or cornering maneuvers.

Consequence

This condition could result in sudden loss of vehicle control increasing the potential for a vehicle accident.

Remedy

Dealers will replace the four rear axle u-bolts on the affected vehicles.

This recall on nhtsa.gov