1998 Chevrolet S10 recalls

Exterior lighting › Headlights

• Aftermarket equipment: applies only if this part was installed

Summary

Dope, Inc. Is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.

Consequence

Decreased lighting visibility may result in a vehicle crash.

Remedy

Dope, Inc. Will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on July 28, 2009. Owners may contact dope, Inc. At 1-626-272-1798.

This recall on nhtsa.gov

Exterior lighting

• Aftermarket equipment: applies only if this part was installed

Summary

Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.

Consequence

Decreased lighting visibility may result in a vehicle crash.

Remedy

Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.

This recall on nhtsa.gov

Fuel system, other › Storage › Tank assembly › Pressure relief devices

• Aftermarket equipment: applies only if this part was installed

Summary

Certain delphi fuel pressure regulators, p/nos. FP10020-11B1, FP10026-11B1, and FP10027-11B1, sold after January 9, 2007, as aftermarket equipment for various passenger vehicles listed above. The universal pressure regulators (upr) were produced without an o'ring and retainer.

Consequence

Fuel may leak, possibly resulting in a fire.

Remedy

Delphi will notify owners and replace the upr free of charge. The recall began on April 23, 2007. Owners can contact delphi at 877-411-8770.

This recall on nhtsa.gov

Exterior lighting

• Aftermarket equipment: applies only if this part was installed

Summary

Certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Consequence

Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.

Remedy

Aj motorsport will notify owners and offer reimbursement for the lamps. The recall began on July 31, 2006. Owners may contact aj motorsport at 626-618-2026.

This recall on nhtsa.gov

Exterior lighting

• Aftermarket equipment: applies only if this part was installed

Summary

Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."

Consequence

Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash

Remedy

Aai motorsports will notify owners and replace the lamps free of charge. The recall began on August 1, 2006. Owners may contact aai motorsports at 909-923-9188.

This recall on nhtsa.gov

Electrical system › 12V/24V/48V battery

Summary

Vehicle description: electric passenger vehicles and pickup trucks containing a nickel metal hydride (nimh) battery pack. These vehicles contain software within the battery pack module intended to disable the vehicle from being driven if the electrical resistance with the battery pack exceeds a prescribed value. Affected vehicles will illuminate the "service now" and "reduced performance" telltales and continue to function in a reduced performance model instead of being disabled.

Consequence

If the telltales are ignored and the affected vehicle continues to be driven, heat could build up and a fire could result.

Remedy

Dealers will install revised software in the battery pack module.

This recall on nhtsa.gov

Exterior lighting

Summary

Vehicle description: light duty pickup trucks and sport utility vehicles. These vehicles fail to comply with the requirements of FMVSS no. 108, "lamps, reflective devices, and associated equipment." the daytime running lights built with a candela value greater than 3,000 cannot be mounted higher than 864MM above the road surface.

Consequence

These vehicles do not comply with requirements of FMVSS no. 108.

Remedy

Dealers will install a revised wiring harness that changes the drl's from high beam to low beam drl's, and install new long-life low beam bulbs.

This recall on nhtsa.gov

Service brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittings

Summary

Vehicle description: electric pickup trucks. A condition in which the fuel-fired heater fill pipe ground strap contacts the rear passenger side brake pipe.

Consequence

This could wear off the corrosion protection on the brake pipe, leading to premature corrosion and eventual loss of brake pipe integrity. When brake pipe integrity is lost, brake fluid leakage can occur.

Remedy

Dealers will relocate the ground strap attachment, inspect the brake pipe for wear, and replace the brake pipe if necessary.

This recall on nhtsa.gov

Visibility › Defroster/defogger/HVAC system

Summary

Vehicle description: light duty pickup trucks equipped with electric drive. Rapid fogging of the interior glass can occur within two minutes after the heat is turned on if (1) the outside temperature is between 35 and 76 degrees fahrenheit and (2) water has collected on the heat exchanger during previous operation of the air conditioning.

Consequence

If rapid fogging were to occur during driving, it could obstruct the driver's vision increasing the risk of a vehicle crash.

Remedy

Owners are being provided with a caution label and supplemental insert for their owner's manual advising them to follow a "stop and wait" procedure to help avoid window fogging while driving.

This recall on nhtsa.gov

Electrical system › Wiring › Front underhood

Summary

Vehicle description: light duty pickup trucks and multi-purpose vehicles. An engine electrical wiring-harness clip can melt and drip onto the exhaust manifold.

Consequence

The clip material on the exhaust manifold can ignite and subsequently ignite other combustible components resulting in a vehicle fire.

Remedy

Dealers are contacting owners by telephone to have their vehicles towed to the dealer and alternate transportation provided to them until the dealer can reroute the electrical wiring-harness.

This recall on nhtsa.gov

Service brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittings

Summary

Vehicle description: light duty pickup trucks and multi-purpose passenger vehicles. A fatigue fracture of the rear axle right-hand brake pipe can occur causing a slow brake fluid leak resulting in a soft brake pedal. If the brake pipe breaks, the driver would experience a sudden drop in the brake pedal, the instrument panel brake light would illuminate, and there would be a loss of rear brake performance.

Consequence

Partial loss of braking at a time when minimum stopping distance was required could result in a vehicle crash.

Remedy

Dealers will inspect and replace the brake pipe.

This recall on nhtsa.gov