2002 Dodge Dakota recalls

Exterior lighting › Headlights

• Aftermarket equipment: applies only if this part was installed

Summary

Dope, Inc. Is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.

Consequence

Decreased lighting visibility may result in a vehicle crash.

Remedy

Dope, Inc. Will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on July 28, 2009. Owners may contact dope, Inc. At 1-626-272-1798.

This recall on nhtsa.gov

Exterior lighting

• Aftermarket equipment: applies only if this part was installed

Summary

Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.

Consequence

Decreased lighting visibility may result in a vehicle crash.

Remedy

Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.

This recall on nhtsa.gov

Suspension › Front › Hub

• Aftermarket equipment: applies only if this part was installed

Summary

Skf is recalling 2,805 hub units, part no. BR930361, sold as a service part for 1997-2004 Dodge dakota vehicles and 1999-2003 Dodge durango vehicles equipped with 2-wheel drive & rear axle ABS. Due to a specification error, the rotor pilot for the hub unit may be too long. This results in the wheel to not be seated fully against the hub flange face during mounting.

Consequence

Improper seating of the wheel can result in excessive vibration, brake rotor noise, difficulty removing the wheel after installation and operation of the vehicle, and possibly wheel-end separation during vehicle operation. Should wheel-end separation occur, the driver could loose control of the vehicle, possibly resulting in a crash.

Remedy

Skf will notify owners and replace the defective hub units free of charge. The recall began on November 5, 2008. Owners may contact skf vsm north america customer service at 1-800-644-8999.

This recall on nhtsa.gov

Power train › Automatic transmission › Lever and linkage › Column shift

Summary

On certain van and pickup trucks equipped with automatic transmissions, the ignition/park shift interlock system may become inoperative. This can allow the shifter to be moved out of the "park" position with the ignition key removed (or in the "lock" position). This can also allow the ignition key to be removed when the shifter has not been placed in the "park" position.

Consequence

Either of these conditions could allow the vehicle to roll away causing a crash without warning.

Remedy

Dealers will replace the gearshift blocker and bracket assembly free of charge. The recall is expected to begin during January 2008. Owners may contact Chrysler at 1-800-853-1403.

This recall on nhtsa.gov

Exterior lighting

• Aftermarket equipment: applies only if this part was installed

Summary

Certain aj motorsport combination lamps sold as replacement lamps for use on the above listed passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Consequence

Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.

Remedy

Aj motorsport will notify owners and offer reimbursement for the lamps. The recall began on July 31, 2006. Owners may contact aj motorsport at 626-618-2026.

This recall on nhtsa.gov

Exterior lighting

• Aftermarket equipment: applies only if this part was installed

Summary

Certain pro-a motors corner lamps, turn signals, and headlights sold as replacement lamps for use on certain passenger vehicles listed above. Some combination lamps that are not equipped with amber side reflectors fail to conform to federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.

Consequence

Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash without warning.

Remedy

Pro-a motors will notify owners and offer to repurchase the lamps. The recall began on April 3, 2006. Owners may contact pro-a motors at 323-838-2988.

This recall on nhtsa.gov

Engine and engine cooling

• Aftermarket equipment: applies only if this part was installed

Summary

Certain replacement k&n fuel performance kits, p/nos. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, and 57-1530. Also, a small percentage of these kits were sold under the mopar performance parts brand name (p/nos. P5007069 and P5007070). All kits were manufactured from April 20, 1999, through September 23, 2004. These assemblies were manufactured as replacement equipment for certain Dodge pickup trucks and SUVS. A small piece of material from the tube wall could be sucked into the engine throttle body, which could cause the throttle to become jammed in the open position.

Consequence

A jammed open throttle could cause unintended acceleration of the vehicle, possibly resulting in a crash or increased stoping distances when braking.

Remedy

K&n will provide owners with a free repair kit along with repair instructions. The recall began on April 20, 2006.

This recall on nhtsa.gov

Fuel system, gasoline › Delivery › Fuel pump

• Aftermarket equipment: applies only if this part was installed

Summary

Certain aftermarket airtex electric fuel pumps installed for use as replacement equipment for certain 1997-2004 Jeep wrangler; 1997-2001 Jeep cherokee; 1997-2004 Jeep grand cherokee; and 2000-2003 Dodge dakota vehicles. The plastic electrical grommet connectors at the top of the fuel pump module are not compatible with automotive fuels and may degrade causing a potential leak path for fuel.

Consequence

In the presence of an ignition source, a fuel leak could result in a fire.

Remedy

Airtex will notify its customers and will replace the affected fuel pumps free of charge. The recall began on January 25, 2006. Owners may contact airtex customer service department at 1-800-880-3056.

This recall on nhtsa.gov

Suspension › Front › Control arm › Upper ball joint

Summary

On certain sport utility vehicles and pickup trucks equipped with four-wheel drive (4X4), if moisture leaks into the front suspension upper ball joint, evacuation of the lubricant and corrosion of the joint may cause the joint to wear over an extended period of time. This could cause a clunking noise in the front suspension, which may not always be heard by the vehicle occupants.

Consequence

Excessive wear in the upper ball joint may allow it to separate, which could result in loss of control of the vehicle.

Remedy

Dealers will replace the front suspension upper ball joints. This safety improvement campaign began on December 21, 2004. Owners can contact daimlerchrysler at 1-800-853-1403.

This recall on nhtsa.gov

Visibility › Windshield wiper/washer

Summary

On certain pickup trucks and sport utility vehicles, the windshield wiper module motor may be susceptible to water intrusion that could cause internal corrosion and result in partial or complete loss of front windshield wiping capability.

Consequence

Driver visibility could be reduced, which could result in a crash.

Remedy

Dealers will replace the front windshield wiper module. Owner notification began on July 12, 2004. Owners should contact daimlerchrysler at 1-800-853-1403.

This recall on nhtsa.gov

Equipment › Other › Labels

Summary

On certain minivans and 4X2 pickup trucks, the vehicle certification label may have gross axle weight ratings (GAWR) that exceed the maximum tire load capacity as defined in federal motor vehicle safety standard no. 120, "tire selection and rims for motor vehicles other than passenger cars."

Consequence

Improperly loading your vehicle can cause tire failure and result in a crash.

Remedy

Owners will be provided with vehicle certification label overlays containing corrected information relative to vehicle GAWR and tire size. Owner notification began March 1, 2004. Owners should contact daimlerchrysler at 1-800-992-1997.

This recall on nhtsa.gov

Electrical system › Wiring

Summary

On certain pickup trucks equipped with manual transmissions, the headlamp and dash wiring harness may be chafed by the actuation of the clutch pedal. This could result in abnormal operation of the wipers, turn signals, horn or lighting systems.

Consequence

This could affect driver visibility, could prevent a driver from sounding a warning by using the horn, and, when the turn signals are inoperative, the driver cannot use them to signal intent to turn, increasing the risk of a crash.

Remedy

Dealers will reroute the wire harness and repair the harness if necessary. Owner notification began November 3, 2003. Owners should contact daimlerchrysler at 1-800-992-1997.

This recall on nhtsa.gov