2001 Dodge Durango recalls

Suspension › Front › Hub

• Aftermarket equipment: applies only if this part was installed

Summary

Skf is recalling 2,805 hub units, part no. BR930361, sold as a service part for 1997-2004 Dodge dakota vehicles and 1999-2003 Dodge durango vehicles equipped with 2-wheel drive & rear axle ABS. Due to a specification error, the rotor pilot for the hub unit may be too long. This results in the wheel to not be seated fully against the hub flange face during mounting.

Consequence

Improper seating of the wheel can result in excessive vibration, brake rotor noise, difficulty removing the wheel after installation and operation of the vehicle, and possibly wheel-end separation during vehicle operation. Should wheel-end separation occur, the driver could loose control of the vehicle, possibly resulting in a crash.

Remedy

Skf will notify owners and replace the defective hub units free of charge. The recall began on November 5, 2008. Owners may contact skf vsm north america customer service at 1-800-644-8999.

This recall on nhtsa.gov

Power train › Automatic transmission › Lever and linkage › Column shift

Summary

On certain van and pickup trucks equipped with automatic transmissions, the ignition/park shift interlock system may become inoperative. This can allow the shifter to be moved out of the "park" position with the ignition key removed (or in the "lock" position). This can also allow the ignition key to be removed when the shifter has not been placed in the "park" position.

Consequence

Either of these conditions could allow the vehicle to roll away causing a crash without warning.

Remedy

Dealers will replace the gearshift blocker and bracket assembly free of charge. The recall is expected to begin during January 2008. Owners may contact Chrysler at 1-800-853-1403.

This recall on nhtsa.gov

Electrical system

Summary

On certain sport utility vehicles equipped with front bench seats only, if fluid is spilled from the floor mounted cup holder, an unused console power outlet connector located under the seat may become contaminated.

Consequence

This may allow development of a high resistive short circuit in the connector, which could eventually lead to a fire.

Remedy

Dealers will inspect the console wiring connector for corrosion, clean as required, and install a cap to prevent additional fluid from contaminating the connector free of charge. The recall began on October 30, 2006. Owners may contact daimler Chrysler at 1-800-853-1403.

This recall on nhtsa.gov

Engine and engine cooling

• Aftermarket equipment: applies only if this part was installed

Summary

Certain replacement k&n fuel performance kits, p/nos. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, and 57-1530. Also, a small percentage of these kits were sold under the mopar performance parts brand name (p/nos. P5007069 and P5007070). All kits were manufactured from April 20, 1999, through September 23, 2004. These assemblies were manufactured as replacement equipment for certain Dodge pickup trucks and SUVS. A small piece of material from the tube wall could be sucked into the engine throttle body, which could cause the throttle to become jammed in the open position.

Consequence

A jammed open throttle could cause unintended acceleration of the vehicle, possibly resulting in a crash or increased stoping distances when braking.

Remedy

K&n will provide owners with a free repair kit along with repair instructions. The recall began on April 20, 2006.

This recall on nhtsa.gov

Suspension › Front › Control arm › Upper ball joint

Summary

On certain sport utility vehicles and pickup trucks equipped with four-wheel drive (4X4), if moisture leaks into the front suspension upper ball joint, evacuation of the lubricant and corrosion of the joint may cause the joint to wear over an extended period of time. This could cause a clunking noise in the front suspension, which may not always be heard by the vehicle occupants.

Consequence

Excessive wear in the upper ball joint may allow it to separate, which could result in loss of control of the vehicle.

Remedy

Dealers will replace the front suspension upper ball joints. This safety improvement campaign began on December 21, 2004. Owners can contact daimlerchrysler at 1-800-853-1403.

This recall on nhtsa.gov

Power train › Automatic transmission › Lever and linkage › Column shift

Summary

Vehicle description: light duty trucks and sport utility vehicles equipped with 4-wheel drive. The electric shift transfer case may not fully engage into gear when the operator moves the transfer case selector switch.

Consequence

This could cause the transfer case to end up in the neutral position unexpectedly and allow the vehicle to roll away if the parking brake is not applied.

Remedy

Dealers will reprogram the transfer case control module. Owner notification began April 9, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

This recall on nhtsa.gov

Child seat

Summary

Vehicle description: certain passenger vehicles, pickup trucks and sport utility vehicles fail to comply with the requirements of FMVSS no. 225, "child restraint anchorage systems." some of the owner's manuals for these vehicles are missing instructions that provide a step-by-step procedure, including diagrams, for properly attaching a child restraint system's tether strap to the tether anchorage.

Consequence

In the event of a crash, the child seat may not be properly attached increasing the risk of injury to the child.

Remedy

Owners will be provided with an addendum to the owner's manuals.

This recall on nhtsa.gov