2001 Dodge Ram recalls

Exterior lighting › Headlights

• Aftermarket equipment: applies only if this part was installed

Summary

Dope, Inc. Is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.

Consequence

Decreased lighting visibility may result in a vehicle crash.

Remedy

Dope, Inc. Will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on July 28, 2009. Owners may contact dope, Inc. At 1-626-272-1798.

This recall on nhtsa.gov

Exterior lighting

• Aftermarket equipment: applies only if this part was installed

Summary

Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.

Consequence

Decreased lighting visibility may result in a vehicle crash.

Remedy

Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.

This recall on nhtsa.gov

Exterior lighting › Headlights

• Aftermarket equipment: applies only if this part was installed

Summary

K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. These headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."

Consequence

Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.

Remedy

K2 motor will notify owners and offer a full refund. The recall began on decemeber 17, 2008. Owners may contact K2 motor at 1-909-839-2992.

This recall on nhtsa.gov

Equipment › Electrical

• Aftermarket equipment: applies only if this part was installed

Summary

Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel RV travel trailers. Due to incorrect wiring of the harness, the trailer lights may not operate properly.

Consequence

If the trailer lights are not working properly, a vehicle crash can occur.

Remedy

All of the defective tow packages are still at the distributor level and have not been sold to any consumers.

This recall on nhtsa.gov

Exterior lighting

• Aftermarket equipment: applies only if this part was installed

Summary

Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."

Consequence

Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash

Remedy

Aai motorsports will notify owners and replace the lamps free of charge. The recall began on August 1, 2006. Owners may contact aai motorsports at 909-923-9188.

This recall on nhtsa.gov

Service brakes, hydraulic › Antilock/traction control/electronic limited slip › Control unit/module

Summary

On certain van and wagon vehicles equipped with 4-wheel antilock brake systems (ABS), aftermarket batteries may leak electrolyte onto the ABS control module connector, which can compromise sealing integrity of the connector.

Consequence

This may allow development of a short circuit in the connector, which could eventually lead to a fire.

Remedy

Dealers will inspect the ABS control module connector for electrolyte damage and replace the connector as necessary. The recall will begin on September 27, 2004. Owners should contact daimlerchrysler at 1-800-853-1403.

This recall on nhtsa.gov

Electrical system › Alternator/generator/regulator

Summary

On certain pickup trucks, the alternator wire connection to the power distribution center (pdc) can loosen.

Consequence

This could cause a vehicle fire.

Remedy

Dealers will inspect the installation of the alternator wire connection to the pdc and if necessary, reposition the wire so that the crimp connection will face upward and tighten the fastener to the correct torque setting. Owner notification began may 20, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

This recall on nhtsa.gov

Tires

Summary

Vehicle description: certain 2500 wagons were equipped with incorrect load range tires.

Consequence

This could cause a tire to blow out if the vehicle is operated at the maximum gross vehicle weight..

Remedy

Dealers will replace the load range 'd' tires with correct load range 'e' tires. Owner notification began September 24, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

This recall on nhtsa.gov

Electrical system › Wiring

Summary

Vehicle description: vans and wagons not equipped with power front seats. In the presence of road salt, water, and possibly other debris, the power seat connector located beneath the driver's seat could develop a high resistive short circuit that cycles the circuit breaker.

Consequence

If the circuit breaker cycles for an extended period of time, heat could build up in the connector, possibly resulting in a fire.

Remedy

Owners will receive instructions for removing the circuit breaker from the fuse panel. If an owner desires, their dealer can perform the repair. Owner notification began August 27, 2001. Owners who do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

This recall on nhtsa.gov

Wheels › Lugs/nuts/bolts/studs

Summary

Vehicle description: vans. A substitute wheel lug nut tightening process may not have been sufficient to assure proper torque of the lug nuts.

Consequence

Improper wheel lug nut torque could allow a wheel to loosen and cause a crash without warning.

Remedy

Dealers will inspect the wheel lug nuts for proper torque and correct if necessary. Owner notification began June 4, 2001. All owners have been contacted.

This recall on nhtsa.gov

Air bags

Summary

Vehicle description: pickup trucks. Sound deadener material inside the steering wheel could become detached from the cover and housing. Note: the ram pickup trucks were built at the warren assembly plant ("s" in the 11th VIN position) from may 16, 2000 through October 23, 2000; st. Louis north assembly plant ("j" in the 11th VIN position) from may 19, 2000 through October 23, 2000; lago alberto assembly plant ("m" in the 11th VIN position) from may 23, 2000 through October 23, 2000; and saltillo assembly plant ("g" in the 11th VIN position) from may 23, 2000 through October 23, 2000. Important: vehicles that have already had the proper clockspring installed, according to warranty records, have been excluded from this recall. In addition, 1997-2000 model year vehicles that have had a suspect replacement clockspring installed, according to warranty records, have been added to this recall.

Consequence

When this occurs, the material could interfere with the clockspring ribbon and cause an open circuit. The driver air bag system will become disabled, and the air bag warning lamp will illuminate on the instrument panel.

Remedy

Dealers will replace the clockspring assembly. Owner notification began June 18, 2001. Also some 1997-200 model year vehicles that, according to warranty records, have had a suspect replacement clockspring installed, will also be included in this campaign. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

This recall on nhtsa.gov

Suspension › Rear

Summary

Vehicle description: quad cab pickup trucks equipped with a camper package and overload springs. The rear axle spacer plate could lead to deformation of the upper spring plate during assembly of the axle to the vehicle resulting a soft joint.

Consequence

The soft joint could cause the rear axle u-bolts to lose clamp load, resulting in displacement of the rear axle and a loss of vehicle control. This could increase the risk of a crash.

Remedy

Dealers will remove the spacer plates and the spring plates will be replaced. Owner notification began February 5, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1-800-853-1403.

This recall on nhtsa.gov

Child seat

Summary

Vehicle description: certain passenger vehicles, pickup trucks and sport utility vehicles fail to comply with the requirements of FMVSS no. 225, "child restraint anchorage systems." some of the owner's manuals for these vehicles are missing instructions that provide a step-by-step procedure, including diagrams, for properly attaching a child restraint system's tether strap to the tether anchorage.

Consequence

In the event of a crash, the child seat may not be properly attached increasing the risk of injury to the child.

Remedy

Owners will be provided with an addendum to the owner's manuals.

This recall on nhtsa.gov

Suspension › Front › Control arm › Upper arm

Summary

Vehicle description: quad cab pickup trucks. The upper control arms attached with cadmium coated nuts can cause the bolts to stretch due to the application of a higher than specified clamp load. Breakage of the upper control arm fasteners could cause the axle to rotate forward under braking conditions.

Consequence

This rotation could twist the steering linkage and possibly separate the brake lines, increasing the risk of a crash.

Remedy

Dealers will replace the upper control arm bolts and nuts.

This recall on nhtsa.gov