2000 Ford F-350 recalls

Equipment › Electrical

• Aftermarket equipment: applies only if this part was installed

Summary

Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel RV travel trailers. Due to incorrect wiring of the harness, the trailer lights may not operate properly.

Consequence

If the trailer lights are not working properly, a vehicle crash can occur.

Remedy

All of the defective tow packages are still at the distributor level and have not been sold to any consumers.

This recall on nhtsa.gov

Vehicle speed control

Summary

On certain trucks equipped with speed control, gasoline or natural gas engines, the speed control deactivation switch may overheat.

Consequence

Overheating could result in smoke or burn and an underhood fire.

Remedy

Dealers will install a fused wiring harness into the speed control system free of charge. The recall began on August 7, 2006. Owners may contact Ford at 1-866-436-7332. (note: also see recalls 05V017 and 05V388)

This recall on nhtsa.gov

Visibility › Windshield wiper/washer › Motor

Summary

Vehicle description: passenger cars, sport utility vehicles, and light and medium duty pickup trucks. A switch located in the plastic cover of the wiper motor gear case could malfunction and overheat, potentially resulting in loss of intermittent wiper function, loss of wiper park function, complete loss of wiper function, or ignition of the plastic cover material. Switch malfunction is most likely to occur when the intermittent setting of the wipers is being used, or when snow or ice obstructs the blades from returning to the "parked" position at the bottom of the windshield. These vehicles were built at the following assembly plants: atlanta plant from 2/11/00 through 7/31/00; chicago plant from 2/14/00 through 8/4/00; kansas city plant from 2/26/00 to 9/4/00; kentucky truck plant from 2/18/00 to 8/31/00; michigan truck plant from 2/23/00 through 8/3/00; norfolk plant from 2/21/00 through 7/27/00; wayne stamping and assembly plant from 2/25/00 through 8/15/00; and wixom plant from 2/15/00 through 8/8/00.

Consequence

Loss of visibility while driving increases the risk of a crash.

Remedy

Dealers will inspect the date code on the wiper motor. Motors built with the suspect time frame will have the wiper motor gear case cover replaced. Owner notification began August 20, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Ford at 1-866-436-7332.

This recall on nhtsa.gov

Fuel system, gasoline › Storage › Tank assembly

Summary

Vehicle description: pickup trucks equipped with gasoline engines and 8 foot boxes, may not fully satisfy the requirements of FMVSS no. 301, "fuel system integrity." in a 30 MPH frontal barrier crash test, a fuel tank vapor recovery valve separated internally. During the subsequent static rollover test, fuel spillage exceeded the specified rate.

Consequence

Fuel leakage, in the presence of an ignition source, could result in a fire.

Remedy

Dealers will install a stop plate assembly on the vehicle frame to prevent recovery valve contact with a frame crossmember during the impact sequence.

This recall on nhtsa.gov

Fuel system, gasoline › Storage › Tank assembly

Summary

Vehicle description: gasoline and diesel engine pickup trucks equipped with 8 foot beds, do not fully satisfy the requirements of FMVSS no. 301, "fuel system integrity." the fuel tank front strap isolator may not be properly positioned which could result in the strap cutting the tank during a 30 MPH front barrier test, resulting in fuel spillage.

Consequence

During the subsequent static rollover test, fuel spillage exceeded the specified rate, increasing the risk of a fire.

Remedy

Dealers will reposition the front strap isolator.

This recall on nhtsa.gov