Skip to content
AnyRecalls

2009 Peterbilt 320 recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

4 recalls found in NHTSA data as of September 22, 2026

For the 2009 Peterbilt 320. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Peterbilt been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Peterbilt dealer can also check your VIN. Recall repairs are free.

2009 Peterbilt 320 recalls, newest first

June 14, 2019NHTSA 19V452000343 vehicles potentially affected

Exterior lighting › Turn signal

Summary
PACCAR Incorporated (PACCAR) is recalling certain 1990-2020 Peterbilt 320 and 520 vehicles built with specific amber rear turn signals. The turn signals may also light up with the stop/tail lights when the brakes are applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence
Rear Turn signals that illuminate at the same time as the brake lights may create confusion and impair the effectiveness of the brake lights, increasing the risk of a crash.
Remedy
PACCAR will notify owners, and for trucks with rear amber lights, dealers will add a jumper harness between the chassis electrical harness and amber tail lights, free of charge. The recall began August 1, 2019. Owners may contact PACCAR customer service at 1-940-591-4220. PACCAR's number for this recall is 19PBC.
Components
Exterior lighting › Turn signal; Exterior lighting › Tail lights

This recall on nhtsa.gov

May 26, 2015NHTSA 15V3090004,823 vehicles potentially affected

Engine and engine cooling › Engine

Summary
PACCAR Incorporated (PACCAR) is recalling certain model year 2010-2016 Kenworth T440, T800, and W900 trucks manufactured August 31, 2009, to April 20, 2015, and 2008-2015 Peterbilt 320, 337, 348, 365, 382, and 384 trucks manufactured July 27, 2007, to April 28, 2015, and equipped with certain Cummins Westport ISL G engines. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.
Consequence
If engine oil comes into contact with a hot surface, there is an increased risk of a fire.
Remedy
Cummins will notify owners on behalf of PACCAR, and Cummins service centers will administer the repairs which include securing the ends of the 90-degree elbow and reprogramming the electronic control module (ECM) with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of charge. The recall began on June 12, 2015. Owners may contact Kenworth customer service at 1-425-828-5000, Peterbilt customer service at 1-940-591-4000 or Cummins Inc. at 1-800-343-7357. PACCAR's number for this recall is 15KWH and 515-G.

This recall on nhtsa.gov

February 24, 2015NHTSA 15V1080005,141 vehicles potentially affected

Steering › Linkages › Tie rod assembly

Summary
PACCAR Incorporated (PACCAR) is recalling certain model year 2009-2015 Peterbilt 320, 365, 367, 388, and 389 trucks manufactured July 21, 2008, to February 28, 2014. The front axle tie rod end clamp bolts may be improperly torqued.
Consequence
Undertorqued tie rod end clamp bolts are susceptible to corrosion, which may cause loose bolts to separate resulting in a loss of vehicle control and an increased risk of a crash.
Remedy
PACCAR will notify owners, and dealers will replace the front axle tie rod assembly on any vehicle where the factory installed assembly has not been previously replaced, free of charge. Owners were mailed interim notices on May 11, 2015. The recall began on April 4, 2016. Owners may contact Peterbilt customer service at 1-940-591-4220. PACCAR's number for this recall is 215-C.

This recall on nhtsa.gov

October 3, 2008NHTSA 08V51000060 vehicles potentially affected

Engine and engine cooling › Engine › Diesel

Summary
Paccar is recalling 60 my 2008-2009 320 trucks equipped with caterpillar C13 diesel engines. The extension pipes attached to the aftertreatment regeneration device (ard) may develop a hole, and heat and flame may escape during a regeneration of the diesel particulate filter.
Consequence
This may result in a fire hazard.
Remedy
Paccar is working with caterpillar to repair this vehicle (please see 08E054). Owners may contact caterpillar at 1-800-447-4986 or peterbilt at 940-591-4196.

This recall on nhtsa.gov

Owner complaints

No owner complaints about the 2009 Peterbilt 320 were found in NHTSA’s complaint data.

Other Peterbilt 320 years

Other 2009 Peterbilt models

Most recalled 2009 vehicles

  1. 2009 Blue Bird All American (33 recalls)
  2. 2009 Blue Bird Vision (28 recalls)
  3. 2009 Ford E-350 (27 recalls)
  4. 2009 Freightliner Cascadia (24 recalls)
  5. 2009 Spartan Gladiator (23 recalls)
All of 2009’s most recalled vehicles

Questions

Does the 2009 Peterbilt 320 have any recalls?
4 recalls found in NHTSA data as of September 22, 2026, covering: exterior lighting, engine and engine cooling, steering. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2009 Peterbilt 320 recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Peterbilt dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2009 Peterbilt 320?
0 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.