2004 Pontiac Grand Prix recalls

Engine and engine cooling › Exhaust system › Manifold/header/muffler/tail pipe

Summary

General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.

Consequence

Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.

Remedy

The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engine’s front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will instead receive the improved remedy under the original recall number. The recall began on February 19, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020, Buick customer service at 1-800-521-7300, Oldsmobile customer service at 1-800-442-6537 and Pontiac customer service at 1-800-458-8006. GM's number for this recall is 15757. Note: Until the improved remedy has been applied, owners are advised to park their vehicle outside since the fire risk exists even when the vehicle is unattended.

Components

Engine and engine cooling › Exhaust system › Manifold/header/muffler/tail pipe; Engine and engine cooling › Engine

This recall on nhtsa.gov

Engine and engine cooling › Engine

Summary

General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004 Pontiac Grand Prix vehicles manufactured January 6, 2003, to June 25, 2004. In the affected vehicles, the valve cover gasket may leak.

Consequence

The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.

Remedy

GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at 1-800-762-2737 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 14574.

This recall on nhtsa.gov

Electrical system › Ignition

Summary

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Consequence

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy

GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

This recall on nhtsa.gov

Exterior lighting › Headlights

• Aftermarket equipment: applies only if this part was installed

Summary

Dope, Inc. Is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.

Consequence

Decreased lighting visibility may result in a vehicle crash.

Remedy

Dope, Inc. Will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on July 28, 2009. Owners may contact dope, Inc. At 1-626-272-1798.

This recall on nhtsa.gov

Steering

• Aftermarket equipment: applies only if this part was installed

Summary

Dorman is recalling 979 steering knuckles, dorman p/nos. 697-902 and 697-903, sold under dorman's "oe solutionstm" brand name, and napa p/nos. 7-8502 and 7-8503 which were sold for replacement use on the various vehicles listed above. A potential material or design defect could result in the steering knuckle breaking in the hub area.

Consequence

A broken steering knuckle could result in loss of steering control and a possible crash without warning.

Remedy

Dorman will notify owners and replace the defective steering knuckles free of charge and reimburse the repair facility or owner for labor. The recall began on February 23, 2009. Owners may contact dorman's toll-free hotline at 1-800-523-2492 and press 5.

This recall on nhtsa.gov

Vehicle speed control › Accelerator pedal

Summary

Certain passenger vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 124, 'accelerator control systems.' if one of the two accelerator pedal return springs fails and the temperature is -22 degrees f to -40 degrees f, the engine may not return to idle within three seconds, as required.

Consequence

If this were to occur, greater brake pedal force and a longer distance may be required to stop the vehicle.

Remedy

Dealers will replace the accelerator pedal assembly. This recall began on March 8, 2005. Owners may contact Cadillac at 1-866-982-2339 or Pontiac at 1-800-620-7668.

This recall on nhtsa.gov

Structure › Frame and members

Summary

Certain passenger vehicles have a condition where the front frame rear body mount bracket may fracture.

Consequence

If ignored, the bracket would fracture and degrade to the point where the intermediate steering shaft could separate, resulting in loss of steering control and a crash could occur.

Remedy

Dealers will inspect the front frame assembly and replace it if necessary. The recall began on August 16, 2004. Owners should contact Pontiac at 1-800-620-7668.

This recall on nhtsa.gov

Service brakes, hydraulic

Summary

Certain passenger vehicles were produced with lower than specified torque on both front brake caliper to steering knuckle attachment bolts. With improper torque, the clamp load at the joint may not be adequate to prevent movement between the caliper bracket and knuckle.

Consequence

Depending on whether one or both bolts backs out or fractures, the result can be locking of the affected wheel during braking and an abrupt steering input in the direction of the locked wheel, reduced braking and noise from the affected wheel, or severing of a brake hose, increased brake pedal travel, and reduced steering control. Reduced braking or steering control could cause a crash.

Remedy

Dealers are to tighten both bolts to the specified torque. Owner notification began on June 28, 2004. Owners should contact Chevrolet 1-800-630-2438 or Pontiac 1-800-620-7668.

This recall on nhtsa.gov

Service brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittings

Summary

Certain passenger vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 135, "passenger car braking systems." on some of these vehicles, the right rear brake hose fitting may not be tightened properly, and a brake fluid leak could occur.

Consequence

If enough fluid leaks, the brake pedal will be lower than normal, and stopping distances will be longer. If this occurs when stopping distance is limited, a crash could occur.

Remedy

Dealers will tighten the right rear brake hose fitting to the proper torque specification, and add brake fluid if necessary. Owner notification began August 28, 2003. Owners should contact Pontiac at 1-800-620-7668.

This recall on nhtsa.gov