Skip to content
AnyRecalls

2007 Sterling L-Line recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

8 recalls found in NHTSA data as of September 22, 2026

For the 2007 Sterling L-Line. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Sterling been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Sterling dealer can also check your VIN. Recall repairs are free.

2007 Sterling L-Line recalls, newest first

September 16, 2011NHTSA 11V47800073,500 vehicles potentially affected

Fuel system, diesel

Summary
Daimler trucks is recalling certain model year 2004 through 2008 heavy trucks manufactured from July 11, 2003, through September 28, 2007, equipped with EPA04 model MBE4000 engines built with plastic low pressure fuel lines and fuel filters mounted near the center of the engine on the left-hand side. The plastic low pressure fuel line between engine mounted fuel filter and engine block may develop a substantial diesel fuel leak.
Consequence
This could create a road hazard increasing the risk of a crash. Fuel leakage, in the presence of an ignition source, could result in a fire.
Remedy
Daimler trucks will notify owners and the remedy will be performed by detroit diesel corporation authorized repair facilities. Vehicles will be inspected and the plastic low pressure fuel line will be replaced with a steel low pressure fuel line. This service will be performed free of charge. An interim letter was mailed to owners on October 28, 2011. The safety recall began on February 21, 2012. Owners may contact daimler trucks at 1-800-547-0712.

This recall on nhtsa.gov

February 25, 2011NHTSA 11V1360002,013 vehicles potentially affected

Fuel system, other

Summary
Daimler trucks is recalling certain model year 2005-2007 sterling l-line vehicles configured with car hauler bodies and chassis, and equipped with EPA04 MBE4000 engines with a fuel filter mounted at the rear of the engine, manufactured from September 13, 2004, through October 10, 2007. The lower low pressure fuel lines between the primary fuel pump and the engine mounted fuel filter, and the upper low pressure fuel line between the engine mounted fuel filter and the engine block may develop a substantial diesel fuel leak from cracking, or from abrasion due to contact with other components.
Consequence
Fuel leak onto the roadway could cause a slippery road surface that could result in a crash.
Remedy
Dealers will replace the upper and lower low pressure fuel lines with a more robust fuel lines. This service will be performed free of charge. Dtna will notify owners of the recall during April 2011. The safety recall began on November 1, 2011. Owners may contact daimler trucks at 1-800-547-0712.

This recall on nhtsa.gov

September 23, 2009NHTSA 09V36600025,362 vehicles potentially affected

Engine and engine cooling

Summary
Daimler trucks is recalling model year 2004-2010 trucks equipped with caterpillar C15 engine. The variable valve actuation oil line may rub against the p-clips retaining the oil line, causing an oil leak.
Consequence
An oil leak may result in a fire.
Remedy
Daimler trucks is working with caterpillar to remedy these vehicles. Please see caterpillar's defect report 09E-020. Caterpillar will inspect and repair the necessary components free of charge. The recall began on may 5, 2009. Owners may contact caterpillar toll-free at 1-800-447-4986 or daimler trucks at 1-800-547-0712.

This recall on nhtsa.gov

March 11, 2008NHTSA 08V11300062,000 vehicles potentially affected

Fuel system, diesel

Summary
Daimler trucks is recalling 62,000 my 2005-2007 freightliner business class, century class, columbia, coronado, fld, classic, sterling a-line, l-line, and western star 4900 trucks. A fractured fuel line could leak diesel fuel.
Consequence
If a leak continues undetected under certain conditions, fuel may ignite at a hot engine surface and/or fuel may be spilled on the road surface.
Remedy
High pressure fuel lines and transfer tubes will be inspected and replaced free of charged. The recall began on July 9, 2008. Owners may contact daimler trucks at 1-800-547-0712.

This recall on nhtsa.gov

November 13, 2007NHTSA 07V53000038,000 vehicles potentially affected

Trailer hitches › Fifth wheel assembly

Summary
On certain truck-tractors equipped with holland simplex se or se II fifth wheels, the latch lever pivot bolt assembly may have been over-tightened which could distort the pivot bolt spacer sleeve. Corrosion or contaminates in the pivot may cause it to bind and prevent the fifth wheel jaw from latching securely around the trailer king pin.
Consequence
There is a possibility that the fifth wheel may fail to latch without the driver's knowledge. When the occurs, the driver could drive away and the trailer could become disengaged increasing the risk of a crash.
Remedy
Dealers will replace the pivot bolt and sleeve with a hex head shoulder bolt and washer. The recall began on January 3, 2008. Owners may contact freightliner at 1-800-547-0712.

This recall on nhtsa.gov

August 1, 2007NHTSA 07V3330001,042 vehicles potentially affected

Wheels › Lugs/nuts/bolts/studs

Summary
On certain trucks built with axilok rear wheel spindle nuts, the nuts may have been improperly installed, with one or both locking clip tabs not properly engaged or damaged.
Consequence
This may reduce the nut's ability to resist rotation, potentially allowing the nut to back off and the dual wheel set to separate from the vehicle, resulting in a crash without prior warning.
Remedy
Dealers will inspect the axilok nuts for locking clip engagement or damage. They will be adjusted or replaced free of charge. The recall began on August 10, 2007. Owners may contact freightliner at 800-547-0712.

This recall on nhtsa.gov

July 18, 2007NHTSA 07V30600018,000 vehicles potentially affected

Steering

Summary
Freightliner is recalling certain school bus chassis, heavy trucks, van chassis, RV motorhome chassis manufactured from January 5 to may 17, 2007, equipped with axle alliance company (aac) front axles. During the front axle assembly, the fasteners that attach the steering arm or tie rod arms to the spindle may be over or under tightened.
Consequence
Incorrectly tightened steering arm fasteners may fatigue and fracture which could cause a crash without warning.
Remedy
Thomas built will notify owners, inspect the fasteners, and replace the steering arm if necessary. The recall began on December 21, 2007. Owners can contact freightliner at 1-800-547-0712.

This recall on nhtsa.gov

July 16, 2007NHTSA 07V30200075,000 vehicles potentially affected

Service brakes, air › Supply › Check valve

Summary
Certain freightliner school bus chassis, heavy trucks, and thomas built school buses manufactured between July 2002 and July 3, 2007, equipped with bendix SR-7 spring brake control valves. The parker scv brass 90 degree single check valves (scv) which attach to the supply port of a bendix SR-7 spring brake modulating valve can break apart. Pieces of the parker scv can become lodged inside the SR-7 spring brake modulating valve, potentially causing either leakage out of the SR-7 valve or preventing air from properly exhausting from the SR-7 valve. Also, due to a manufacturing defect in the internal rubber check valve inside the SR-7 spring brake modulating valves, the valves can become deformed and not seat properly.
Consequence
These conditions could either result in leakage and cause a delay in the application of the spring brake without warning or possibly lead to unintended vehicle rollaway or brake drag which could result in a vehicle crash, personal injury, or death.
Remedy
Freightliner will notify owners and repair the vehicles free of charge. The recall began on January 11, 2008 to freightliner, sterling, and freightliner custom chassis owners; to thomas built bus owners on February 1, 2008. Owners can contact freightliner at 1-800-547-0712.

This recall on nhtsa.gov

Owner complaints

Owners have filed 3 complaints about the 2007 Sterling L-Line with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported
0
Fires reported
0
Injuries reported
1
Deaths reported
0

Most complained-about components

  1. Diesel2
  2. Fuel system2
  3. Steering1
  4. Tires1

Other Sterling L-Line years

Other 2007 Sterling models

Most recalled 2007 vehicles

  1. 2007 Ford E-350 (35 recalls)
  2. 2007 Freightliner Columbia (27 recalls)
  3. 2007 Ford E-250 (27 recalls)
  4. 2007 Thomas Built Buses SAF-T-Liner C2 (25 recalls)
  5. 2007 Thomas Built Buses Minotour (23 recalls)
All of 2007’s most recalled vehicles

Questions

Does the 2007 Sterling L-Line have any recalls?
8 recalls found in NHTSA data as of September 22, 2026, covering: fuel system, diesel, fuel system, other, engine and engine cooling, trailer hitches, wheels, steering. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2007 Sterling L-Line recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Sterling dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2007 Sterling L-Line?
3 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.