2001 Volkswagen Jetta recalls

Engine and engine cooling › Engine

• Aftermarket equipment: applies only if this part was installed

Summary

The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

Consequence

A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.

Remedy

Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.

This recall on nhtsa.gov

Exterior lighting › Brake lights › Switch

Summary

On certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

Consequence

The brake lights could become inoperative, or remain on. Failure to provide the proper signal when braking could lead to a crash without warning.

Remedy

Dealers will install the newly designed brake light switch free of charge. The recall began on April 27, 2007, and will be conducted in several staggered mailings through September 21, 2007. Vehicles within the make, model, and model year of this population may be involved in either this recall or 06V-183, but not both. The remedy is the same for each recall. Volkswagen dealers will apply the remedy based on the VIN number of the vehicle. Owners may contact VW at 1-800-822-8987.

This recall on nhtsa.gov

Exterior lighting › Brake lights › Switch

Summary

On certain passenger vehicles equipped with automatic or manual transmissions and cruise controls, a brake light switch on these vehicles may malfunction if it was installed incorrectly during safety recalls 03V-265 or 04V-096.

Consequence

The brake lights could become inoperative, or remain on. Failure to provide the proper signal when braking could lead to a crash without warning.

Remedy

Dealers will install the newly designed brake light switch free of charge. The recall began on November 27, 2006. Vehicles within the make, model, and model year of this population may be involved in either this recall or 06V-183, but not both. The remedy is the same for each recall. Volkswagen dealers will apply the remedy based on the VIN number of the vehicle. Owners may contact VW at 1-800-822-8987.

This recall on nhtsa.gov

Exterior lighting › Hazard flashing warning lights › Switch

Summary

On certain passenger vehicles, the hazard switch and flasher system function may degrade over time because of distortion and material transfer of the contacts of certain hazard switch relays which occurs due to substantially increased electrical current load from higher wattage turn signal bulbs.

Consequence

This may result in intermittent or inoperative turn signal and hazard flasher function.

Remedy

Dealers will replace the hazard flasher switch/relay kit. The recall began on March 31, 2005. Owners should contact Volkswagen at 1-800-822-8987.

This recall on nhtsa.gov

Exterior lighting › Brake lights › Switch

Summary

On certain passenger vehicles, a brake light switch on these vehicles may malfunction.

Consequence

If this happens, the brake lights could become inoperative, or come on and stay on, even though the vehicle is parked.

Remedy

This recall has been superceded by 06V-183. Owners who have had a remedy performed under this recall should return to their dealer for the redesigned remedy. Owners should contact Volkswagen at 1-800-822-8987.

This recall on nhtsa.gov

Equipment › Other › Owners/service/other manual

Summary

Certain passenger vehicles fail to comply with requirements of federal motor vehicle safety standard no. 225, "child restraint anchorage systems." child seat anchorages installed in the vehicle's rear seats must be identified by markings, and their location and use be described in the owner's manual.

Consequence

These vehicles were not marked or described as required by the standard.

Remedy

Owners will be provided with a supplement for the owner's manual and also one set of four guidance fixtures intended to use in conjunction with child seats equipped with rigid or semi-rigid lower anchorage attachments. Also enclosed will be four decals together with installation instructions and a template for attaching the decals to the lower seat backs. Owner notification is expected to begin September 15, 2002. Owners should contact vwoa at 1-800-822-8987.

This recall on nhtsa.gov

Service brakes, hydraulic › Antilock/traction control/electronic limited slip

Summary

On some passenger vehicles, short circuits can occur within the electronic control unit of the anti-lock braking system (ABS).

Consequence

This can result in a fire.

Remedy

Dealers will replace the ABS control unit. Owner notification began March 8, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Volkswagen at 1-800-822-8987.

This recall on nhtsa.gov