2005 Volkswagen Jetta recalls

Service brakes, hydraulic › Foundation components › Master cylinder

• Aftermarket equipment: applies only if this part was installed

Summary

Tenneco Automotive (Tenneco) is recalling certain Beck/Arnley Master Cylinders, part number 072-9831, sold as aftermarket or replacement parts for 2004-2018 Volkswagen Jetta, and 2012-2019 Volkswagen Beetle vehicles. The fluid seal crimp on the master cylinder may be insufficient, causing brake fluid to leak or the cylinder to come apart.

Consequence

If there is a brake fluid leak, it can reduce braking ability, increasing the risk of a crash.

Remedy

Beck/Arnley will notify the distributors that sold the master cylinders and will work with the distributors to notify the end users. Affected master cylinders will be exchanged for a new master cylinder (part number 072-9990), free of charge. The recall began October 30, 2020. Owners may contact Tenneco customer service at 1-800-625-9319.

This recall on nhtsa.gov

Engine and engine cooling › Engine

• Aftermarket equipment: applies only if this part was installed

Summary

The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

Consequence

A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.

Remedy

Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.

This recall on nhtsa.gov

Exterior lighting › Headlights

Summary

Certain vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." some vehicles may not have had a required cap installed which disables the headlight horizontal aim and some vehicles may contain a cap that disables the vertical aiming screw.

Consequence

Noncompliance can inhibit proper headlamp aim adjustment for roadway illumination, improperly aimed headlamps could cause reduced road visibility, increasing the risk of a crash.

Remedy

Dealers will inspect for the presence of a cap in the socket of the low beam horizontal aiming screw and install one if missing, and inspect for the presence of a cap in the socket of the vertical aiming screw and if present, the cap will be removed. The recall will begin on October 31, 2007. Owners may contact VW at 1-800-822-8987.

This recall on nhtsa.gov

Service brakes, hydraulic › Foundation components › Master cylinder

• Aftermarket equipment: applies only if this part was installed

Summary

Certain cardone master cylinders with part numbers 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, and 11-3156, and with date codes lower than DCA7078 sold as replacement equipment for use on the vehicles listed above. The seal on master cylinder can fail and leak brake fluid.

Consequence

Loss of brake fluid can result in poor braking performance, possibly resulting in a vehicle crash.

Remedy

Cardone will notify owners and offer to repurchase any defective master cylinders. The recall began during April 2007. Owners can contact cardone at 1-800-777-4780.

This recall on nhtsa.gov

Exterior lighting › Brake lights › Switch

Summary

On certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

Consequence

The brake lights could become inoperative, or remain on. Failure to provide the proper signal when braking could lead to a crash without warning.

Remedy

Dealers will install the newly designed brake light switch free of charge. The recall began on April 27, 2007, and will be conducted in several staggered mailings through September 21, 2007. Vehicles within the make, model, and model year of this population may be involved in either this recall or 06V-183, but not both. The remedy is the same for each recall. Volkswagen dealers will apply the remedy based on the VIN number of the vehicle. Owners may contact VW at 1-800-822-8987.

This recall on nhtsa.gov

Fuel system, gasoline › Delivery › Hoses, lines/piping, and fittings

Summary

On certain passenger vehicles equipped with a 2.5L gasoline engine, a fuel supply line clamp located in the engine compartment may not be positioned properly and could cause a fuel leak.

Consequence

Fuel leakage, in the presence of an ignition source, could result in a fire.

Remedy

Dealers will inspect the position of the engine compartment fuel supply line clamp and, if necessary, replace the clamp. The recall began on July 11, 2005. Owners may contact VW at 1-800-822-8987.

This recall on nhtsa.gov

Fuel system, diesel

Summary

On certain passenger vehicles, the high pressure diesel pumps were produced with an improper fastener, which could allow diesel fuel to escape from the pump.

Consequence

Fuel leakage in the presence of an ignition source may lead to a fire.

Remedy

Dealers will replace the diesel pump. The recall began on February 8, 2005. Owners should contact Volkswagen at 1-800-822-8987.

This recall on nhtsa.gov