Skip to content
AnyRecalls

1991 Volkswagen Jetta recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

7 recalls found in NHTSA data as of September 22, 2026

For the 1991 Volkswagen Jetta. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Volkswagen been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. Recall repairs are free.

1991 Volkswagen Jetta recalls, newest first

April 7, 2009NHTSA 09E01200016,270 vehicles potentially affected

Exterior lighting

  • Aftermarket equipment: applies only if this part was installed
Summary
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence
Decreased lighting visibility may result in a vehicle crash.
Remedy
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.

This recall on nhtsa.gov

March 1, 2006NHTSA 06E018000266 vehicles potentially affected

Service brakes, hydraulic

  • Aftermarket equipment: applies only if this part was installed
Summary
Certain hydraulic brake hoses, p/n 171.611.107B, sold as replacement equipment for 1975-1985 Volkswagen (VW) rabbit; 1985-1992 VW golf; and 1980-1992 VW jetta passenger vehicles. Possible brake hose rupture could occur which fails to comply with the requirements of federal motor vehicle safety standard no. 106, "brake hoses."
Consequence
Brake hose rupture could result in loss of braking ability, possibly resulting in a vehicle crash.
Remedy
Foreign parts distributors will notify owners and replace the brake hoses with compliant brake hoses. The recall began on March 30, 2006. Owners may contact foreign parts distributors at 305-885-8646 ext. 11.

This recall on nhtsa.gov

August 2, 1993NHTSA 93V12900076,000 vehicles potentially affected

Service brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittings

Summary
An engine preheating tube may not be properly supported due to a missing support bracket, causing the preheating tube to chafe against the right front metal brake line. This can damage the hydraulic line, causing brake fluid leakage and diminished braking in one brake circuit.
Consequence
Diminished braking can result in increased stoppingdistances and a possible accident.
Remedy
Dealers will install a preheating tube support bracket to ensure proper positioning relative to the right front metal brake line.

This recall on nhtsa.gov

September 15, 1992NHTSA 92V13100012,650 vehicles potentially affected

Vehicle speed control

Summary
The venturi tube located in the throttle valve housing can become loose and fall against the throttle plate.
Consequence
The venturi tube can partially block the throttle plateand prevent it from returning to its full idle position, resulting in unwantedengine speed when the vehicle is placed in a forward or reverse gear.
Remedy
Replace the press-fit venturi tube with a thread type tube.

This recall on nhtsa.gov

April 14, 1992NHTSA 92V058000358,000 vehicles potentially affected

Fuel system, gasoline › Delivery › Hoses, lines/piping, and fittings

Summary
The fuel hose attached to the fuel distribution rail on the engine may shrink beyond the clamp force of the fuel hose clamps, allowing fuel to leak.
Consequence
Fuel leakage in the engine compartment can cause an underhood fire if the fuel comes in contact with a source of ignition.
Remedy
Replace the fuel hose attached to the fuel rail and install a new spring type self-tightening clamp.

This recall on nhtsa.gov

April 15, 1991NHTSA 91V064000550 vehicles potentially affected

Vehicle speed control › Linkages

Summary
The lock nut of the cruise control rod for the operating servo may not have been properly torqued during manufacture.
Consequence
Inadequate torque of the lock nut could allow the rodadjustment to change. This could increase the engine idle speed, and possiblyincrease stopping distance with a potential for a vehicle accident.
Remedy
Check and assure proper lock nut torque on the cruise control rod.

This recall on nhtsa.gov

Owner complaints

Owners have filed 31 complaints about the 1991 Volkswagen Jetta with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported
2
Fires reported
0
Injuries reported
2
Deaths reported
0

Most complained-about components

  1. Visibility › Defroster/defogger/HVAC system › Heater core5
  2. Electrical system › Alternator/generator/regulator3
  3. Vehicle speed control3
  4. Engine and engine cooling › Cooling system2
  5. Seat belts › Front › Anchorage2

Other Volkswagen Jetta years

Other 1991 Volkswagen models

Most recalled 1991 vehicles

  1. 1991 Honda Accord (13 recalls)
  2. 1991 Blue Bird TC2000 (12 recalls)
  3. 1991 Acura Integra (11 recalls)
  4. 1991 Thomas School Bus (11 recalls)
  5. 1991 Chevrolet Caprice (10 recalls)
All of 1991’s most recalled vehicles

Questions

Does the 1991 Volkswagen Jetta have any recalls?
7 recalls found in NHTSA data as of September 22, 2026, covering: exterior lighting, service brakes, hydraulic, vehicle speed control, fuel system, gasoline. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 1991 Volkswagen Jetta recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Volkswagen dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 1991 Volkswagen Jetta?
31 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.