Does the 1994 Volvo 850 have any recalls?

3 recalls found in NHTSA data as of September 22, 2026, covering: fuel system, gasoline, engine and engine cooling, vehicle speed control. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.

How do I check if my 1994 Volvo 850 recall has been fixed?

Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Volvo dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.

How many complaints have owners filed about the 1994 Volvo 850?

83 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.

1994 Volvo 850 recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

3 recalls found in NHTSA data as of September 22, 2026

For the 1994 Volvo 850. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Volvo been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

Check your VIN with NHTSA

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Volvo dealer can also check your VIN. Recall repairs are free.

1994 Volvo 850 recalls, newest first

July 30, 2004NHTSA 04V368000226,000 vehicles potentially affected

Fuel system, gasoline › Storage

Summary: On certain passenger vehicles, after prolonged exposure to heat, the fuel tank may seep or leak fuel at the points where the heat shield is attached.
Consequence: Fuel leakage, in the presence of an ignition source, could result in a fire.
Remedy: Volvo will inspect the fuel tank and replace it if any evidence of fuel seepage or leakage is found. All vehicles will receive new reinforcement bushings at the heat shield attachment points to prevent future leaks. This recall will be conducted as a safety recall in the hot weather states of alabama, arkansas, arizona, california, florida, georgia, hawaii, louisiana, mississippi, nevada, new mexico, north carolina, oklahoma, south carolina, tennessee, texas, and utah, and as a service recall in the other 33 states and the district of columbia. The recall began on September 24, 2004. Owners may contact Volvo at 1-800-458-1552.

This recall on nhtsa.gov

August 20, 1996NHTSA 96E025000400 vehicles potentially affected

Engine and engine cooling › Engine › Gasoline

Aftermarket equipment: applies only if this part was installed

Summary: Engine block heaters installed as accessories. The block heater contact surface does not match correctly with the engine block as intended. The block heater could come loose from the engine block, and if being used, could possibly overheat causing damage if it comes in contact with other engine compartment components.
Consequence: Engine compartment damage could occur increasing the risk of a vehicle accident.
Remedy: Dealers will inspect the block heater and secure the bolts used to install the heater. In some cases, the surface tolerances may be so inappropriate that the heater would need to be replaced with a heater of a modified design.

This recall on nhtsa.gov

September 13, 1994NHTSA 94V17300014,000 vehicles potentially affected

Vehicle speed control

Summary: Under very cold weather conditions, ice crystals can form at the throttle in the engine intake system, and prevent the throttle from returning to idle.
Consequence: This condition can cause loss of speed control and can result in unwanted acceleration and a possible accident.
Remedy: Dealers will replace the throttle body, throttle cable, charge air cooler piping and crankcase ventilation hoses.

This recall on nhtsa.gov

Owner complaints

Owners have filed 83 complaints about the 1994 Volvo 850 with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported: 6
Fires reported: 3
Injuries reported: 10
Deaths reported: 0

Most complained-about components

Fuel system12
Air bags › Frontal6
Gasoline › Storage › Tank assembly6
Service brakes6
Tires6

Other Volvo 850 years

Other 1994 Volvo models

Most recalled 1994 vehicles

1994 Dodge Ram (22 recalls)
1994 Blue Bird TC2000 (15 recalls)
1994 Honda Civic (14 recalls)
1994 Chevrolet C10 (14 recalls)
1994 Honda Accord (13 recalls)

All of 1994’s most recalled vehicles

Questions

Does the 1994 Volvo 850 have any recalls?: 3 recalls found in NHTSA data as of September 22, 2026, covering: fuel system, gasoline, engine and engine cooling, vehicle speed control. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 1994 Volvo 850 recall has been fixed?: Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Volvo dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 1994 Volvo 850?: 83 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.