Skip to content
AnyRecalls

2005 Ford F-150 recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

13 recalls found in NHTSA data as of September 22, 2026

For the 2005 Ford F-150. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Ford been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. Recall repairs are free.

2005 Ford F-150 recalls, newest first

February 23, 2011NHTSA 11V1070001,325,000 vehicles potentially affected

Air bags › Frontal › Driver side › Inflator module

Summary
Ford is recalling certain model year 2004-2006 F-150 pick up trucks as well as certain model year 2006 Lincoln mark lt vehicles. If the clockspring jumper wire comes in contact with the driver side frontal air bag lower horn plate, the wire insulation may become chafed, creating a potential for a short circuit. If this occurs the air bag warning lamp may illuminate indicating that service is required.
Consequence
The driver side frontal air bag could inadvertently deploy increasing the risk of injury or loss of vehicle control if occurring while in motion.
Remedy
Ford will notify owners and instruct them to take their vehicles to a Ford or Lincoln/Mercury dealer to have a new clockspring jumper wire installed that incorporates a protective mesh cover. Repairs will be performed free of charge. This safety recall began on some vehicles in March 2011. The recall campaign on the expanded population is expected to begin on or about may 9, 2011. Owners may contact the Ford motor company customer relationship center at 1-866-436-7332.

This recall on nhtsa.gov

May 11, 2009NHTSA 09E02500042,540 vehicles potentially affected

Exterior lighting › Headlights

  • Aftermarket equipment: applies only if this part was installed
Summary
Dope, Inc. Is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence
Decreased lighting visibility may result in a vehicle crash.
Remedy
Dope, Inc. Will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on July 28, 2009. Owners may contact dope, Inc. At 1-626-272-1798.

This recall on nhtsa.gov

April 7, 2009NHTSA 09E01200016,270 vehicles potentially affected

Exterior lighting

  • Aftermarket equipment: applies only if this part was installed
Summary
Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.
Consequence
Decreased lighting visibility may result in a vehicle crash.
Remedy
Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.

This recall on nhtsa.gov

May 7, 2008NHTSA 08V208000605,684 vehicles potentially affected

Service brakes, hydraulic › Power assist › Vacuum › Hoses, lines/piping, and fittings

Summary
Ford is recalling 605,684 my 2005-2006 F-150 and Lincoln mark lt vehicles equipped with 5.4L 3-valve engines. The brake booster vacuum supply hose attached to the intake manifold fitting may swell over time and lose retention force. This condition could allow the hose to become detached from the fitting during an intake manifold backfire. Should the hose detach from the intake manifold, several brake applications with power assist will be available before the vacuum reserve is depleted.
Consequence
Once the brake booster vacuum reserve is depleted, the driver will have foundation brake function, but with increased brake pedal effort. Reduced vehicle braking could lead to a crash.
Remedy
Dealers will replace a rubber hose on the brake booster vacuum supply tube assembly. The recall began on June 27, 2008. Owners may contact Ford at 1-800-392-3673.

This recall on nhtsa.gov

October 25, 2007NHTSA 07E089000238 vehicles potentially affected

Exterior lighting › Headlights

  • Aftermarket equipment: applies only if this part was installed
Summary
Certain spyder headlamp replacement assemblies sold for use on 2004 through 2007 Ford F150 pickup trucks. During production, the headlamps were internally misaligned and they fail the photometry requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
The purpose of this standard is to reduce traffic crashes and deaths and injuries by providing adequate illumination of the roadway.
Remedy
Spyder will notify owners and offer a full reimbursement for any noncompliant headlamps. The recall is expected to begin during November 2007. Owners can contact spyder at 866-558-4264.

This recall on nhtsa.gov

September 25, 2007NHTSA 07E080000700 vehicles potentially affected

Exterior lighting › Headlights

  • Aftermarket equipment: applies only if this part was installed
Summary
Certain headlamp assemblies imported and sold as aftermarket equipment by sonar auto parts for use on 2004-2007 Ford F150 pickup trucks. During production, the headlamps were internally misaligned and they fail the photometry requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
The purpose of this standard is to reduce traffic crashes and deaths and injuries by providing adequate illumination of the roadway.
Remedy
Sonar will notify owners and offer a full reimbursement for any noncompliant headlamps. The recall began on December 14, 2007. Owners can contact sonar at 866-558-4264.

This recall on nhtsa.gov

September 14, 2007NHTSA 07E0750002,388 vehicles potentially affected

Exterior lighting › Headlights

  • Aftermarket equipment: applies only if this part was installed
Summary
Certain eagle eyes headlamp assemblies, p/nos. FR390-B001L and FR390-B001R, sold for use as replacement equipment for the above listed passenger vehicles. The thickness is unstable inhibiting the performance of the upper and lower beams which fails to conform to the photometric requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Decreased lighting visibility may result in a vehicle crash.
Remedy
Eagle eyes will notify owners and offer reimbursement for any noncompliant headlights. The recall began on November 6, 2007. Owners may contact eagle eyes at 1-800-568-1098.

This recall on nhtsa.gov

August 28, 2007NHTSA 07E066000175 vehicles potentially affected

Equipment › Electrical

  • Aftermarket equipment: applies only if this part was installed
Summary
Certain cequent 90 degree 7-way right angle adaptors sold by distributors in tow packages for aftermarket sales to tow 5th wheel RV travel trailers. Due to incorrect wiring of the harness, the trailer lights may not operate properly.
Consequence
If the trailer lights are not working properly, a vehicle crash can occur.
Remedy
All of the defective tow packages are still at the distributor level and have not been sold to any consumers.

This recall on nhtsa.gov

July 17, 2006NHTSA 06E0640004,029 vehicles potentially affected

Exterior lighting

  • Aftermarket equipment: applies only if this part was installed
Summary
Certain tradesonic combination lamps sold as replacement lamps for use on the above listed passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, lamps, reflective devices, and associated equipment.
Consequence
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash.
Remedy
Tradesonic will notify owners and replace the lamps free of charge. The recall is expected to begin during July 2006. Owners may contact tradesonic at 626-934-8884.

This recall on nhtsa.gov

June 29, 2006NHTSA 06E06000087,745 vehicles potentially affected

Exterior lighting

  • Aftermarket equipment: applies only if this part was installed
Summary
Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence
Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash
Remedy
Aai motorsports will notify owners and replace the lamps free of charge. The recall began on August 1, 2006. Owners may contact aai motorsports at 909-923-9188.

This recall on nhtsa.gov

June 13, 2006NHTSA 06E05600058,640 vehicles potentially affected

Fuel system, gasoline

  • Aftermarket equipment: applies only if this part was installed
Summary
Certain aftermarket fuel filters sold under the purolator brand name, p/n F65277, shipped from January 16 through June 2, 2006, for use on the above listed passenger vehicles. Due to incorrect design, the quick connectors may not fully seat with the tube interface, even though the person making the connection may believe that the quick connector is fully attached.
Consequence
Failure of this connection could lead to fuel spillage and, in the presence of an ignition source, a fire could occur.
Remedy
Ufi will notify owners and replace the filters free of charge. The recall began on August 4, 2006. Owners may contact ufi filters USA at 800-230-5876.

This recall on nhtsa.gov

March 13, 2006NHTSA 06E023000292,000 vehicles potentially affected

Exterior lighting › Headlights

  • Aftermarket equipment: applies only if this part was installed
Summary
Certain anzo combination headlamp assemblies sold as replacement lamps for use on certain passenger vehicles. Some combination lamps are not equipped with amber side reflectors which fail to conform to federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."
Consequence
Without the amber reflectors, the vehicle will be poorly illuminated, possibly resulting in a vehicle crash.
Remedy
Anzo will notify owners and replace the headlamps free of charge. The recall began may 9, 2006. Owners may contact anzo USA at 909-468-3688.

This recall on nhtsa.gov

February 6, 2006NHTSA 06V033000211,432 vehicles potentially affected

Interior lighting

Summary
Certain pickup trucks fail to comply with either the requirements of federal motor vehicle safety standard (FMVSS) no. 105, 'hydraulic and electric brake systems' or FMVSS no. 135, 'passenger car brake systems.' these vehicles were built with a software error in the instrument cluster.
Consequence
This error could prevent the antilock brake system (ABS) warning light from illuminating if the ABS module ever became inoperative.
Remedy
Dealers will recalibrate the instrument cluster in these vehicles. The recall began on February 27, 2006. Owners may contact Ford at 1-800-392-3673.

This recall on nhtsa.gov

Owner complaints

Owners have filed 1,112 complaints about the 2005 Ford F-150 with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported
50
Fires reported
29
Injuries reported
57
Deaths reported
2

Most complained-about components

  1. Visibility › Power window devices and controls181
  2. Service brakes120
  3. Engine117
  4. Engine and engine cooling77
  5. Air bags69

Other Ford F-150 years

Other 2005 Ford models

Most recalled 2005 vehicles

  1. 2005 Honda Accord (24 recalls)
  2. 2005 Ford E-350 (16 recalls)
  3. 2005 IC CE (16 recalls)
  4. 2005 Thomas Built Buses SAF-T-Liner C2 (16 recalls)
  5. 2005 Honda Pilot (15 recalls)
All of 2005’s most recalled vehicles

Questions

Does the 2005 Ford F-150 have any recalls?
13 recalls found in NHTSA data as of September 22, 2026, covering: air bags, exterior lighting, service brakes, hydraulic, equipment, fuel system, gasoline, interior lighting. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2005 Ford F-150 recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Ford dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2005 Ford F-150?
1,112 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.