Skip to content
AnyRecalls

2019 Gillig LOW Floor recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

12 recalls found in NHTSA data as of September 22, 2026

For the 2019 Gillig LOW Floor. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Gillig been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Gillig dealer can also check your VIN. Recall repairs are free.

2019 Gillig LOW Floor recalls, newest first

February 11, 2025NHTSA 25V07600091 vehicles potentially affected

Equipment › Appliance › Tv/radio/speakers

Summary
Gillig, LLC (Gillig) is recalling certain 2019-2024 Low Floor transit buses. The rivet-nut fasteners that secure the TFT flat panel display monitor to the bus ceiling may fail, causing the monitor to detach and fall.
Consequence
A monitor that detaches and falls from the ceiling increases the risk of injury.
Remedy
Gillig will replace the rivet-nut fasteners, free of charge. Owner notification letters were mailed March 18, 2025. Owners may contact Gillig customer service at 1-800-735-1500.

This recall on nhtsa.gov

November 3, 2023NHTSA 23V7400004,286 vehicles potentially affected

Power train › Driveline › Driveshaft

Summary
Gillig, LLC (Gillig) is recalling certain 2019-2023 Low Floor transit buses. The transmission yoke may separate, resulting in driveshaft separation and a sudden loss of drive power.
Consequence
A sudden loss of drive power can increase the risk of a crash. Additionally, a disabled bus may require an evacuation procedure in an uncontrolled traffic situation, increasing the risk of injury to passengers.
Remedy
Gillig will work with the equipment manufacturer, Allison Transmission Inc., to inspect and tighten the transmission yoke bolts, as necessary, free of charge. Owner notification letters were mailed December 11, 2023. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.

This recall on nhtsa.gov

July 28, 2022NHTSA 22V548000184 vehicles potentially affected

Electrical system › Propulsion system › Traction battery

Summary
Gillig, LLC (Gillig) is recalling certain 2019-2022 Low Floor vehicles equipped with Cummins BP74E battery packs. The battery packs may develop a coolant leak internally, causing the battery pack to short circuit.
Consequence
A battery short circuit increases the risk of a fire.
Remedy
Gillig will tighten the coolant fittings and replace the coolant, free of charge. Owner notification were mailed on August 16, 2022. Owners may contact Gillig's customer service at 1-510-264-5073 or 1-800-735-1500.

This recall on nhtsa.gov

June 17, 2022NHTSA 22V436000169 vehicles potentially affected

Electrical system › Propulsion system › Cables › Fastener/connector

Summary
Gillig, LLC (Gillig) is recalling certain 2019-2022 Low Floor electric transit buses. The EV resolver cable connector may experience a loss of electrical connectivity, unexpectedly switching from Drive to Neutral with no warning.
Consequence
An unexpected switch to neutral can cause a loss of vehicle propulsion and increase the risk of a crash.
Remedy
Dealers will install a redesigned resolver cable with extended length and a new support bracket, free of charge. Owner notification letters were mailed on August 3, 2022. Owners may contact Gillig's customer service at 1-510-264-5073 or 1-800-735-1500.

This recall on nhtsa.gov

April 25, 2022NHTSA 22V276000592 vehicles potentially affected

Electrical system › 12V/24V/48V battery

Summary
Gillig, LLC (Gillig) is recalling certain 2014-2021 Low Floor transit buses. The rear-mounted ultracapacitors may allow the engine to be started when the master battery disconnect switch is in the "OFF" position.
Consequence
The engine may be started unexpectedly, increasing the risk of injury to anyone nearby the engine compartment during maintenance operations.
Remedy
Dealers will update the software for the buses equipped with the Vanner Ultracapacitor system, and conduct a hard rewire for the buses equipped with the KBI system, free of charge. Owner notification letters were mailed on June 22, 2022. Owners may contact Gillig's customer service at 1-510-264-5073 for 1-800-735-1500.

This recall on nhtsa.gov

May 14, 2021NHTSA 21V3520004,428 vehicles potentially affected

Fuel system, diesel › Fuel injection system › Fuel rail

Summary
Gillig, LLC. (Gillig) is recalling certain 2017-2020 Low Floor vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
Consequence
A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy
Gillig will inspect the rail threads, and replace the rail as necessary, free of charge. Owner notification letters were mailed on August 27, 2021. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.

This recall on nhtsa.gov

July 2, 2020NHTSA 20V392000531 vehicles potentially affected

Steering › Hydraulic power assist › Pump

Summary
Gillig, LLC. (Gillig) is recalling certain 2013-2020 hybrid and all-electric Low Floor buses equipped with a steering system that uses a high-voltage electric motor and hydraulic pump assembly to provide power steering assist. The shaft coupling between the motor and pump may fail and cause a loss of hydraulic power steering assist.
Consequence
A loss of power steering assist may increase the risk of crash.
Remedy
Gillig will notify owners, and dealers will replace the motor-pump assemblies, free of charge. The recall began August 13, 2020. Owners may contact Gillig customer service at 1-800-735-1500.

This recall on nhtsa.gov

June 10, 2020NHTSA 20V3420003,728 vehicles potentially affected

Suspension › Rear

Summary
Gillig LLC (Gillig) is recalling certain 2018-2020 Low Floor buses. The rear suspension lower control rods may experience fatigue failure due to stiffened end bushings.
Consequence
If the rear suspension lower control rod fails, the bus may have reduced handling and stability, increasing the risk of a crash.
Remedy
Gillig will notify owners and provide them with new lower control rods with different bushings, free of charge. This recall began June 26, 2020. Owners may contact Gillig customer service at 1-800-735-1500.

This recall on nhtsa.gov

April 29, 2020NHTSA 20V239000275 vehicles potentially affected

Fuel system, other › Storage › Tank assembly › Pressure relief devices

Summary
Gillig LLC (Gillig) is recalling certain 2018-2020 Low Floor transit buses powered by compressed natural gas (CNG). The thermally activated pressure relief device (PRD) installed on the CNG fuel system may not vent the system when exposed to heat, potentially resulting in the system rupturing.
Consequence
If the fuel system ruptures from exposure to heat, there may be an increased risk of injury.
Remedy
Gillig will work with Agility to notify customers and replace the PRDs, free of charge. The recall began May 15, 2020. Owners may contact Agility customer service at 1-949-267-7745 or Gillig customer service at 1-800-735-1500.

This recall on nhtsa.gov

March 25, 2020NHTSA 20V1790008,224 vehicles potentially affected

Electrical system › Wiring › Fuses and circuit breakers

Summary
Gillig LLC (Gillig) is recalling certain 2012-2020 Low Floor buses. The circuit breaker ratings on the DEF Line Heater circuit and the Aftertreatment-Ignition circuit may be higher than the rating for the wire and connector.
Consequence
With the improper circuit breaker rating, an electrical short in either of these circuits may increase the risk of a fire.
Remedy
Gillig will notify owners, and dealers will replace the circuit breakers, free of charge. The recall began April 24, 2020. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.

This recall on nhtsa.gov

June 14, 2019NHTSA 19V45100025 vehicles potentially affected

Structure › Emergency › Escape/egress/exit

Summary
Gillig LLC (Gillig) is recalling certain 2018-2019 Low Floor vehicles equipped with a certain batch of glass roof hatches. Temperature and vibration stresses may cause the tempered glass roof hatch to shatter.
Consequence
If the tempered glass roof hatch shatters, glass fragments may fall onto passengers, increasing the risk of an injury.
Remedy
Gillig will notify owners, and the glass hatch manufacturer will provide replacement hatch lids, free of charge. The recall began June 27, 2019. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.

This recall on nhtsa.gov

March 8, 2019NHTSA 19V193000965 vehicles potentially affected

Exterior lighting › Headlights

Summary
Gillig LLC (Gillig) is recalling certain 2014-2019 Low Floor buses. Uncovered electrical terminals in the headlight power circuit may short circuit to ground, causing a loss of headlights.
Consequence
A loss of headlights can reduce the driver's ability to see, increasing the risk of a crash.
Remedy
Gillig has notified owners, and dealers will install new back covers on the headlight buckets, free of charge. The recall began April 1, 2019. Owners may contact Gillig customer service at 1-510-264-5073 or 1-800-735-1500.

This recall on nhtsa.gov

Owner complaints

Owners have filed 1 complaint about the 2019 Gillig LOW Floor with NHTSA. Complaints are unverified reports from the public; NHTSA uses them to decide what to investigate.

Crashes reported
0
Fires reported
0
Injuries reported
0
Deaths reported
0

Most complained-about components

  1. Seat belts1

Other Gillig LOW Floor years

Other 2019 Gillig models

Most recalled 2019 vehicles

  1. 2019 Mercedes-Benz Sprinter 2500 (42 recalls)
  2. 2019 Mercedes-Benz Sprinter 3500 (41 recalls)
  3. 2019 Blue Bird Vision (41 recalls)
  4. 2019 Mercedes-Benz Sprinter 4500 (38 recalls)
  5. 2019 Mercedes-Benz Sprinter 1500 (38 recalls)
All of 2019’s most recalled vehicles

Questions

Does the 2019 Gillig LOW Floor have any recalls?
12 recalls found in NHTSA data as of September 22, 2026, covering: equipment, power train, electrical system, fuel system, diesel, steering, suspension. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2019 Gillig LOW Floor recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Gillig dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2019 Gillig LOW Floor?
1 complaint filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.