Does the 2005 Orion V have any recalls?

5 recalls found in NHTSA data as of September 22, 2026, covering: electrical system, engine and engine cooling, power train, interior lighting, equipment adaptive/mobility. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.

How do I check if my 2005 Orion V recall has been fixed?

Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Orion dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.

How many complaints have owners filed about the 2005 Orion V?

0 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.

2005 Orion V recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

5 recalls found in NHTSA data as of September 22, 2026

For the 2005 Orion V. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Orion been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

Check your VIN with NHTSA

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Orion dealer can also check your VIN. Recall repairs are free.

2005 Orion V recalls, newest first

September 27, 2013NHTSA 13V4760003,009 vehicles potentially affected

Electrical system

Summary: Daimler Buses North America Ltd. (DBNA) is recalling certain model year 2003-2008 Orion V and model year 2002-2010 VII buses equipped with Sure Power equalizers and DC-DC Converters. The specific potting compound used in the equalizers and convertors for insulation was found to be capable of conducting electricity after being exposed to heat.
Consequence: Once electrically conductive, the material is capable of melting and burning, increasing the risk of a fire.
Remedy: DBNA will notify owners and Sure Power representatives will change out the equalizer and/or convertor, free of charge. The recall is expected to begin during November 2014. Owners may contact DBNA at 1-905-403-1111.

This recall on nhtsa.gov

September 13, 2012NHTSA 12V447000187 vehicles potentially affected

Engine and engine cooling › Engine › Other fuel types › Turbo/supercharger

Summary: Daimler Buses North America (DBNA) is recalling certain model year 2004-2008 Orion V and model year 2005-2006 Orion VII transit buses equipped with John Deere Compressed Natural Gas (CNG) turbocharged engines. The turbine or compressor wheel may fail, resulting in subsequent damage to the engine and/or an oil leak.
Consequence: Failure of the turbine or compressor wheel may result in smoke, fire, and stalling, increasing the risk of a crash.
Remedy: DBNA will notify owners. The remedy for this issue is still under development. The safety recall began on September 28, 2012. Owners may contact Daimler Buses North America at 1-800-882-8054.

This recall on nhtsa.gov

January 21, 2010NHTSA 10V015000426 vehicles potentially affected

Power train › Clutch assembly › Pedal/hand lever(motorcycle)

Summary: Daimler buses is recalling certain orion transit buses equipped with the morse remote throttle control. The morse remote throttle control panel is located in the engine compartment and a switch on it is labeled, "throttle"; "off" or "front" and "on" or "rear" selecting the active engine control station. If a person operating the engine from the "rear" position (at the engine) fails to place the switch in the "off" or "front" position and the engine rpm was set to above idle during maintenance for example, when the bus is started from the driver's station the engine could change to the higher rpm resulting in unwanted engine power.
Consequence: The bus could accelerate at a higher rate than anticipated increasing the risk of a crash.
Remedy: Daimler will provide instructions to modify the wiring to the morse throttle control switch. This service will be performed free of charge. The safety recall began on April 1, 2010. Owners may contact daimler buses at 1-800-716-7466.

This recall on nhtsa.gov

October 20, 2009NHTSA 09V413000368 vehicles potentially affected

Interior lighting

Summary: Daimler buses of north america is recalling certain model year 2002 through 2009 orion transit buses equipped with luminator horizon LED side destination signs. The connector board can corrode due to an accumulation of moisture under the connector.
Consequence: A short could occur, possibly causing smoke and a fire.
Remedy: Orion will notify owners and the buses will be repaired by luminator free of charge. Please see luminator's defect report 09E-054. The safety recall is expected to begin during November 2009. Owners may contact luminator at 1-972-516-3033 or orion at 1-800-716-7466.

This recall on nhtsa.gov

October 20, 2009NHTSA 09V412000983 vehicles potentially affected

Equipment adaptive/mobility

Summary: Daimler buses is recalling certain model year 2000 through 2008 orion transit buses equipped with lift-u wheelchair lifts. The lifts are equipped with a logic board assembly for the wheelchair lift control box, p/nos. 373-0226 and 373-0265. The outboard ramp barrier could fold in toward a lift passenger and pinch, press, or crush the passenger's feet.
Consequence: The lift passenger could be seriously injured.
Remedy: Orion will notify owners and the repairs will be made by lift-u free of charge. Please see lift-u's defect report 09E-051. The safety recall began on October 29, 2009. Owners may contact lift-u at 1-209-838-2400 or orion at 1-800-716-7466.

This recall on nhtsa.gov

Owner complaints

No owner complaints about the 2005 Orion V were found in NHTSA’s complaint data.

Other Orion V years

Other 2005 Orion models

Most recalled 2005 vehicles

2005 Honda Accord (24 recalls)
2005 Ford E-350 (16 recalls)
2005 IC CE (16 recalls)
2005 Thomas Built Buses SAF-T-Liner C2 (16 recalls)
2005 Honda Pilot (15 recalls)

All of 2005’s most recalled vehicles

Questions

Does the 2005 Orion V have any recalls?: 5 recalls found in NHTSA data as of September 22, 2026, covering: electrical system, engine and engine cooling, power train, interior lighting, equipment adaptive/mobility. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 2005 Orion V recall has been fixed?: Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Orion dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 2005 Orion V?: 0 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.