Skip to content
AnyRecalls

1999 Thomas MVP ER recalls

Source: NHTSA data as of September 22, 2026. Last refreshed Sep 23, 2026, 2:43 AM UTC.

9 recalls found in NHTSA data as of September 22, 2026

For the 1999 Thomas MVP ER. These apply to the model and year, not to one particular vehicle: check your VIN to see whether yours is included and whether it has been repaired.

Has your Thomas been repaired?

Recalls here come from NHTSA’s records for the model and year. Not every vehicle of a model is included in every recall, and this site can’t see whether a repair has been done. Only a VIN lookup can tell you that.

NHTSA’s VIN search doesn’t show recalls that were already repaired, recalls more than 15 years old, or some small manufacturers’ recalls. A Thomas dealer can also check your VIN. Recall repairs are free.

1999 Thomas MVP ER recalls, newest first

July 30, 2008NHTSA 08V3560003,773 vehicles potentially affected

Engine and engine cooling

Summary
Daimler trucks is recalling 3,773 my 1996 through 2002 thomas built mvp er school buses manufactured from June 8, 1995 through February 16, 2001, equipped with caterpillar 3116 and 3126 engines. Un-fused power cables were tie-wrapped to a wire braid engine fuel return hose. Over time these cables may chafe, wearing through the wire loom and eventually through the cable insulation and fuel line covering in an area not easily detectable during normal maintenance without removing the tie wraps and opening the wire loom. Un-fused and un-switched power cables which wear through and contact the fuel line wire braid may short circuit.
Consequence
In the event of a short circuit, a vehicle fire can occur.
Remedy
Thomas built will notify owners and inspect and replace the cables as necessary free of charge. The recall is expected to begin on or about November 28, 2008. Owners may contact thomas built at 1-336-889-4871.

This recall on nhtsa.gov

February 26, 2008NHTSA 08V087000243,435 vehicles potentially affected

Structure › Body › Door › Hinge and attachments

Summary
Daimler trucks is recalling 243,435 my 1995-2008 thomas built school buses manufactured between January 1994, and March 10, 2008. (additional buses have been added to this recall campaign. Please see supplemental report no. 4) the emergency exit door handle begins corroding around the securing roll pin and square drive mechanism causing the protective finish to chip and flake. Continued corrosion and pitting weakens the handle. Handles weakened by corrosion may break while trying to open the door from the exterior.
Consequence
In the event of an emergency, a person on the outside of the bus may break the door handle trying to open the emergency exit potentially delaying evacuation and increasing the risk of personal injury to the vehicle's occupants.
Remedy
Daimler trucks will notify owners and will replace the handles with a more robust handle free of charge. Repairs will be performed by thomas built buses dealerships. The recall began on August 18, 2008, and notification for the revised population is expected to begin on or about April 29, 2009. Owners may contact thomas built at 336-889-4871.

This recall on nhtsa.gov

April 27, 2005NHTSA 05V20500016,000 vehicles potentially affected

Fuel system, diesel

Summary
Certain 1998-2003 my freightliner FS-65 school bus chassis and MB-45, MB-55, and xb shuttle bus chassis, and thomas built bus: mvp-er and mvp-ef school bus and non-school bus models equipped with cummins isb diesel engines and equipped with federal-mogal 12 and 24 volt fuel lift pumps. The fuel pump could fail to transfer fuel appropriately creating an engine stall condition.
Consequence
Should the engine stall while the vehicle is in use, a possible vehicle crash could occur.
Remedy
Cummins will notify the customers of freightliner and thomas built and replace the fuel lift pump free of charge. Owners may contact cummins at 1-800-diesels.

This recall on nhtsa.gov

August 6, 2002NHTSA 02V22100015 vehicles potentially affected

Wheels › Lugs/nuts/bolts/studs

Summary
On certain school and transit buses, the wheel lug nut may not tighten completely.
Consequence
The wheel could loosen increasing the risk of loss of control of the vehicle.
Remedy
Dealers will install new wheel studs. Owner notification began February 28, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 336-889-4871.

This recall on nhtsa.gov

March 20, 2002NHTSA 02V0850004,800 vehicles potentially affected

Engine and engine cooling › Cooling system › Fan

Summary
On certain school buses, misalignment of the fan drive system components can cause premature belt and pulley bearing wear.
Consequence
If the school bus is disabled by a cooling system failure and is stalled on the side of the road, an increased risk of a crash resulting in injury to a school bus occupant could occur.
Remedy
Dealers will replace the fan belt, idler pulley, and belt tensioner and the pulley's laser will be aligned. Owner notification began June 10, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.

This recall on nhtsa.gov

February 21, 2001NHTSA 01V04400216,000 vehicles potentially affected

Steering › Linkages › Tie rod assembly

Summary
Vehicle description: trucks, school bus and motor home chassis, and transit buses equipped with tie rod assemblies manufactured by TRW. The suspect tie rods contain 24-DL model ball sockets. Certain of the tie rod ball-socket bearings have a below-specification case depth and/or hardness, which can lead to premature wear of the socket.
Consequence
If this condition occurs, the driver can lose partial control of the right front wheel, possibly resulting in a crash.
Remedy
Dealers will replace the defective ball sockets and/or drag links. Owner notification began may 22, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712 or TRW customer service at 1-866-280-3287.

This recall on nhtsa.gov

November 3, 2000NHTSA 00V3620006,500 vehicles potentially affected

Seats

Summary
Vehicle description: certain school buses and transit buses equipped with national seating's series 93B-sb driver seat. A bracket attaching the gas spring shock to the height adjuster of the seat can deform and break. This bracket is located at the top of the height adjuster.
Consequence
If the bracket is not replaced after deforming, and is allowed to break, its breaking will result in a sudden drop of the driver's seat, increasing the risk of loss of control of the vehicle and a crash.
Remedy
Dealers will replace the seat base and add reinforcement to the seat assembly

This recall on nhtsa.gov

August 7, 2000NHTSA 00V2320114,780 vehicles potentially affected

Service brakes, air › Antilock

Summary
Vehicle description: school bus chassis and emergency vehicles built with bendix air ABS with an EC-17 1030R electronic control unit (ECU), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
Consequence
This condition could cause the ABS ECU to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
Remedy
Dealers will replace the ABS ECU.

This recall on nhtsa.gov

August 7, 2000NHTSA 00V23200235,405 vehicles potentially affected

Service brakes, air › Antilock

Summary
Vehicle description: heavy duty trucks and school bus chassis built with bendix air ABS with an EC-17 1030R electronic control unit (ECU), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
Consequence
This condition could cause the ABS ECU to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
Remedy
Dealers will replace the ABS ECU.

This recall on nhtsa.gov

Owner complaints

No owner complaints about the 1999 Thomas MVP ER were found in NHTSA’s complaint data.

Other Thomas MVP ER years

Other 1999 Thomas models

Most recalled 1999 vehicles

  1. 1999 Ford F-250 (19 recalls)
  2. 1999 Ford F-150 (18 recalls)
  3. 1999 Honda Accord (17 recalls)
  4. 1999 Chevrolet Silverado (16 recalls)
  5. 1999 Blue Bird All American (16 recalls)
All of 1999’s most recalled vehicles

Questions

Does the 1999 Thomas MVP ER have any recalls?
9 recalls found in NHTSA data as of September 22, 2026, covering: engine and engine cooling, structure, fuel system, diesel, wheels, steering, seats. Recalls apply to the model and year; whether a particular vehicle is included, and whether it has been repaired, depends on its VIN.
How do I check if my 1999 Thomas MVP ER recall has been fixed?
Enter your 17-character VIN at nhtsa.gov/recalls, or ask a Thomas dealer. Recall repairs are free. NHTSA's VIN search doesn't list recalls that were already repaired.
How many complaints have owners filed about the 1999 Thomas MVP ER?
0 complaints filed with NHTSA. Complaints are unverified reports from the public that NHTSA uses to decide what to investigate.