1995 Chevrolet C10 recalls

Exterior lighting › Headlights

• Aftermarket equipment: applies only if this part was installed

Summary

Dope, Inc. Is recalling 42,540 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.

Consequence

Decreased lighting visibility may result in a vehicle crash.

Remedy

Dope, Inc. Will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on July 28, 2009. Owners may contact dope, Inc. At 1-626-272-1798.

This recall on nhtsa.gov

Exterior lighting

• Aftermarket equipment: applies only if this part was installed

Summary

Sabersport is recalling 16,270 combination corner and bumper lamp assemblies of various part numbers sold for use as aftermarket equipment for various passenger vehicles. These headlamps fail to conform to the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." these lamps do not contain the required amber side reflectors.

Consequence

Decreased lighting visibility may result in a vehicle crash.

Remedy

Sabersport will notify owners and offer a full refund for the noncompliant combination lamps. The safety recall began on may 11, 2009. Owners may contact sabersport at 1-909-598-7589.

This recall on nhtsa.gov

Exterior lighting › Headlights

• Aftermarket equipment: applies only if this part was installed

Summary

K2 motor is recalling 1,921 aftermarket headlamps of various models sold for use on the above listed vehicles. These headlamps are missing the amber side reflex reflector which fails to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."

Consequence

Without the amber side reflex reflectors, the lighting visibility may be affected, possibly resulting in a vehicle crash.

Remedy

K2 motor will notify owners and offer a full refund. The recall began on decemeber 17, 2008. Owners may contact K2 motor at 1-909-839-2992.

This recall on nhtsa.gov

Exterior lighting

• Aftermarket equipment: applies only if this part was installed

Summary

Certain aai motorsports combination lamps sold as replacement lamps for use on the above list passenger vehicles. Combination lamps not equipped with amber side reflectors fail to conform with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment."

Consequence

Lack of amber side reflectors in the lamps will decrease lighting visibility to other drivers and may possibly result in a vehicle crash

Remedy

Aai motorsports will notify owners and replace the lamps free of charge. The recall began on August 1, 2006. Owners may contact aai motorsports at 909-923-9188.

This recall on nhtsa.gov

Fuel system, gasoline › Storage › Tank assembly

Summary

Vehicle description: crew cab pickup trucks. The front, inner corner of the fuel tank can contact the body sill either intermittently or constantly. This movement can cause a discernible noise and, over time, can wear a hole in or crack the fuel tank at point of contact.

Consequence

This condition can result in fuel leakage and a distinct fuel odor if the tank were filled above the level of the hole or crack. In the presence of an ignition source, a fire could result.

Remedy

Dealers will inspect the fuel tank for wear and, either install a spacer between the fuel tank and the front crossmember, or if necessary, replace the fuel tank.

This recall on nhtsa.gov

Visibility › Windshield wiper/washer

Summary

Vehicle description: light duty pickup trucks and sport utility vehicles, 2 and 4-wheel drive. Solder joints near the wiring harness connector can crack causing the windshield wipers to work intermittently.

Consequence

This condition can result in inoperative wipers, reducing a driver's visibility, and increasing the risk of a vehicle crash.

Remedy

Dealers will replace the wiper motor circuit board and cover.

This recall on nhtsa.gov

Seats

Summary

Vehicle description: extended cab and 2-door utility vehicles equipped with reclining seats and the easy-entry feature. These vehicles exhibit a condition in which a pinch point exists in the recliner mechanism that can trap and pinch a person's hand or finger(s) when the easy-entry feature is activated.

Consequence

This pinching can cut the hand or possibly sever the finger(s) without prior warning.

Remedy

Dealers will install a protector cover over the recliner mechanism.

This recall on nhtsa.gov

Vehicle speed control

Summary

These vehicles were assembled with the throttle cable contacting the dash mat which could bind the throttle. This does not meet with the maximum return times required by federal motor vehicle safety standard no. 124, "accelerator control systems."

Consequence

Consequence of non-compliance: the engine speed may not return to idle increasing the potential for a vehicle accident.

Remedy

Dealers will inspect for adequate throttle cable to dash mat clearance, and if there is insufficient clearance, cut out a portion of the dash mat to provide proper clearance.

This recall on nhtsa.gov

Seats

• Aftermarket equipment: applies only if this part was installed

Summary

The seat recliner to seat frame attaching bolts on these vehicles could loosen, fatigue and fracture, allowing the seat back to suddenly recline.

Consequence

If this were to occur to the driver's seat, this could result in a sudden loss of vehicle control increasing the risk of a vehicle accident.

Remedy

Dealers will remove all foam and/or fabric sandwiched between the recliner assembly and the seat frame, install washers between the seat recliner and the seat frame at each attachment point, and install new attaching bolts torqued to a higher specification. These corrections will be made to both the driver's and passenger's seats.

This recall on nhtsa.gov

Steering › Steering wheel/handle bar

Summary

The steering column upper intermediate-shaft nut may not be torqued to proper specifications. The nut could loosen and detach allowing the through-bolt that secures the upper intermediate-shaft to the lower steering column shaft joint to fall out.

Consequence

This loose engagement can provide noticeable noise and abnormal steering feeling to the driver and, if left unattended, the steering shafts can separate resulting in a loss of steering control.

Remedy

Dealers will torque the suspect fasteners to the proper specifications.

This recall on nhtsa.gov

Seat belts › Front

Summary

These vehicles were built with front seat belt systems with no energy management loops and may not meet the head injury criteria requirements of FMVSS no. 208, "occupant crash protection."

Consequence

In the event of a vehicle crash, the occupants of these seats may not be properly restrained.

Remedy

Dealers will replace the retractor portion of the seat belt assembly(s) with one having the newly designed energy-management twin-loop system.

This recall on nhtsa.gov

Seat belts › Front

Summary

If both the lap-belt and shoulder-belt energy management loops on the front seat belt assemblies release at or near the same time, acceleration forces can cause the buckle release mechanism to activate and allow the buckle to separate from the latch.

Consequence

If the buckle released, the system would fail to provide adequate occupant restraint protection.

Remedy

Dealers will remove the stitching that creates the energy management loop in the shoulder belt(s).

This recall on nhtsa.gov